Fuel Tank Purging Procedure; Fuel Filler (Tank) Cap; Fuel Lines; Maintenance Services - Suzuki Samurai 1986 Service Manual

Table of Contents

Advertisement

[Fuel tank purging procedure]

WARNING:
This purging procedure will NOT remove
all fuel vapor. Do not attempt any repair
on tank where heat or flame is required, as
an explosion resulting in personal injury
cou Id occur.
The following procedure is used for purging the
fuel tank.
1) After removing fuel tank, remove all hoses,
fuel level gauge from fuel tank.
2) Drain all remaining fuel from tank.
3) Move tank to flushing area.
4) Fill tank with warm water or tap water, and
agitate vigorously and drain. Repeat this
washing until inside of tank is clean.
Replace tank if inside is rusty.
5) Completely flush out remaining water after
washing.
Reverse removal procedure for installation using
care for the following.
Tightening torque
for fuel tank
drain plug
Refer to Fig. 4-2-5 for piping and clamp posi-
tions.
Make sure for correct hose-to-pipe connec-
l
tion.
Clamp hoses securely.
l
Upon completion of installation, start engine
l
and check hose joints for leaks.

MAINTENANCE SERVICES

Fuel Lines

Visually inspect fuel lines and connections for
evidence of fuel leakage, hose cracking, and
damage. Make sure all clamps are secure.
Repair leaky joints, if any.
Replace hoses that are suspected of being crack-
ed.
Nm
30-45
kg-m)
4.5
(22.0 - 32.5 lb-ft)
Fig. 4-2-14

Fuel Filler (tank) Cap

Visually inspect gasket of fuel filler cap.
If it is damaged or deteriorated, replace filler cap
with new one.
NOTE:
If cap requires replacement, only a cap with
the same features should be used. Failure to
use correct cap can result in a serious malfunc-
tion of the system.
Fig. 4-2-15
Fuel Filter
As said before, this filter does not permit dis-
assembly: it is to be replaced with a new one
periodically.
Replace fuel filter referring to previous item of
"Fuel Filter Removal and Installation".
This servicing must be performed in a well
ventilated area and away from any open
flames (such as gas hot water heaters).
2. Fuel filler capgasket
4-35

Hide quick links:

Advertisement

Table of Contents
loading

This manual is also suitable for:

Samurai 1987Samurai 1988

Table of Contents