Yamaha XC125 Service Manual page 15

l'"sPl lAo
CHAPTER 2.
PERiODiC iNSPECTiON AND ADJUSTMENTS
INTRODUCTION .............................................. 2-1
PERIODIC MAINTENANCE/LUBRICATION INTERVALS ............. 2-1
REMOVING THE COVERS AND PANELS .......................... 2-2
SIDE COVER .............................................. 2-2
FRONT COVER ............................................ 2-2
FOOTREST BOARD ........................................ 2-3
FRONT AND REAR LEG SHIELD ............................. 2-3
i_lp" _lmimm
FRONT AND REAR HANDLEBAR COVERS ..................... 2-4 _IIPJ
ENGINE ..................................................... 2-4
VALVE CLEARANCE ADJUSTMENT .......................... 2-4
THROTTLE CABLE ADJUSTMENT ............................ 2-6
IDLE SPEED ADJUSTMENT .................................. 2-6
IGNITION TIMING CHECK ................................... 2-7
FUEL LINE INSPECTION .................................... 2-8
ENGINE OIL LEVEL INSPECTION ............................. 2-8
ENGINE OIL REPLACEMENT ................................ 2-8
FINAL GEAR OIL (SUB TRANSMISSION OIL) REPLACEMENT ..... 2-9
AIR FILTER AND CRANKCASE FILTER CLEANING ............. 2-10
V-BELT INSPECTION ....................................... 2-11
COMPRESSION PRESSURE MEASUREMENT .................... 2-11
SPARK PLUG INSPECTION .................................. 2-12
CHASSIS ..................................................... 2-13
BRAKE LINING INSPECTION ................................ 2-13
FRONT BRAKE ADJUSTMENT ............................... 2-13
REAR BRAKE ADJUSTMENT ................................ 2-14
TIRES AND CAST WHEELS CHECK ............................ 2-14
STEERING HEAD INSPECTION ............................... 2-16
STEERING HEAD ADJUSTMENT .............................. 2-16
ELECTRICAL ................................................. 2-17
BATTERY INSPECTION ..................................... 2-17
HEADLIGHT BULB REPLACEMENT ........................... 2-18
HEADLIGHT BEAM ADJUSTMENT ............................ 2-19
FUSE INSPECTION ......................................... 2-20