Handlebar Switches - Buell X1 2002 Service Manual

HOME

HANDLEBAR SWITCHES

REMOVAL
NOTE
The individual handlebar switches are not repairable.
Replace switch assembly upon switch failure.
Right Side
1. Detach throttle cables. See
2. Remove seat. See 2.40 SEAT.
1 1
WARNING WARNING
The gasoline in the fuel supply line downstream of the
fuel pump is under high pressure (49 psi [338 kPa]). To
avoid an uncontrolled discharge or spray of gasoline,
always purge the system of high pressure gas before
attaching fuel pressure gauge. Gasoline is extremely
flammable and highly explosive. Inadequate safety pre-
cautions could result in death or serious injury.
3. Purge fuel line and remove fuel tank. See
TANK.
4. See Figure 7-48. Cut as many cable straps as necessary
to access right handlebar switch connector [22] along
right side frame tube. Detach connector [22] from wiring
harness.
5. Cut as many cable straps as necessary to access brake
switch connector [21] along right side frame tube. Detach
connector [21] from wiring harness.
Left Side
1. Remove three screws from handlebar switch.
2. Separate switch housings and remove from handlebar.
3. Remove seat. See 2.40
1 1
WARNING WARNING
The gasoline in the fuel supply line downstream of the
fuel pump is under high pressure (49 psi [338 kPa]). To
avoid an uncontrolled discharge or spray of gasoline,
always purge the system of high pressure gas before
attaching fuel pressure gauge. Gasoline is extremely
flammable and highly explosive. Inadequate safety pre-
cautions could result in death or serious injury.
4. Purge fuel line and remove fuel tank. See
TANK.
5. See Figure 7-50. Cut as many cable straps as necessary
to access left handlebar switch connector [24] along right
side frame tube. Detach connector [24] from wiring har-
ness.
6. Cut as many cable straps as necessary to access clutch
switch connector [95] along right side frame tube. Detach
connector [95] from wiring harness.
2002 Buell X1: Electrical
2.24 THROTTLE CONTROL.
4.37 FUEL
SEAT.
4.37 FUEL
IGN POWER
IGN MODULE
FROM [2]
TO STARTER
ACC POWER
TO STOPLIGHT
Figure 7-48. Right Handlebar Switch Connection
6925
1. Ignition ON
2. Ignition OFF
3. Electric Starter
Figure 7-49. Right Handlebar Switches
7.15
b0630x7x
Right Handlebar
Switch [22]
GY/O
BE 4
W/R W/BK
3
GN/BK W/BK
2
BK/R
1
Y/R
1
O/W O/W
R/Y 2 R/Y
Brake Switch [21]
2
1
3
7-37