Air Sutter Ajustment Oven And Broil Burners - Electrolux Next Gen 30" Service Manual

7. Air Shutter-Oven Burner
The air shutter for the oven burner may need adjustment,
especially if the unit has been converted for use with LP/
Propane gas. The approximate flame length of the oven
burner is 1 inch (distinct inner, blue flame) (See Figure
11).
Figure 11
To determine if the oven burner flame is proper:
a. To access the air shutter you must remove the
warmer drawer.
b. Remove the oven bottom by removing the screws at
rear of oven bottom. Lift up the rear of oven bottom
and slide toward back of range to disengage from
front of oven front frame.
c. Remove burner baffle by removing nut located on top
of baffle and two screws from front edge of oven front
frame. Lift baffle straight up and out of the oven.
d. Set the oven to bake at 350°F and observe the flame.
If the flame is yellow in color, increase air shutter
opening size. If the flame is a distinct blue color, but
lifting away from the burner; reduce the air shutter
opening size.
e. Turn off oven and allow to cool before adjusting air
shutter. To adjust loosen lock-screw (See Figure
12), reposition air shutter, and tighten lock-screw.
Figure 12
Retest the burner by repeating step "d" above. When the
burner flame is a distinct blue color burning steady, the
air shutter is adjusted correctly.
f. Replace burner baffle and oven bottom.
Figure 13
8. Air Shutter-Broil Burner
a. Observe the flame to determine if the broiler burner
flame is properly adjusted. It should be steady with
approximately 1" blue cones and no yellow or orange
flame tips (See Figure 13).
b. If adjustment to the air shutter is necessary, locate
the broiler burner air shutter (See figure 14), loosen
shutter lock screw, and adjust to obtain optimum
flame. This will normally be completely open for LP/
Propane gas. If the flame is yellow in color, increase
the air shutter opening size. If the flame is a distinct
blue, but lifting away from the burner, reduce the air
shutter opening size. Tighten the shutter set screw.
Figure 14
9. Replace Storage Drawer or Warmer Drawer
(instructions for warmer drawer if equipped):
24