APRILIA RS 125 Workshop Manual page 16

RS125
BRAKE FLUID
NOTE This vehicle is fitted with front and rear disc brakes. Each braking system is operated by an independent hydraulic
circuit. The information provided below applies to both braking systems.
DANGER
Do not use the vehicle in case brakes are worn out or do not work properly. The brakes are the parts
that most ensure your safety and for this reason they must always be perfectly working. Failure to
comply with these recommendations will probably lead to a crash or an accident, with a consequent
risk of personal injury or death.
A wet surface reduces brakes efficiency.
DANGER
In case of wet ground the braking distance will be doubled, since both brakes and tyre grip on the
road surface are extremely reduced by the water present on the road surface.
Any water on brakes, after washing the vehicle or driving on a wet road surface or crossing puddles
or gips, can wet brakes so as to greatly reduce their efficiency.
Failure to comply with these recommendations may lead to serious accidents, with a consequent risk
of severe personal injuries or death.
Brakes are critical safety components. Do not ride the vehicle in case brakes are not working at their
best.
Check for brakes proper operation before every trip.
Brake fluid is irritant. Avoid contact with eyes or skin.
In the event of accidental contact, wash affected body parts thoroughly. In the event of accidental
contact with eyes, contact an eye specialist or seek medical advice.
DO NOT RELEASE BRAKE FLUID INTO THE ENVIRONMENT.
KEEP AWAY FROM CHILDREN.
When handling brake fluid, take care not to spill it onto plastic or paint-finished parts or they will
damage.
DANGER
Do not use any brake fluids other than the specified type. Never mix different types of fluids to top up
level, as this will damage the braking system.
Do not use brake fluid from old containers which have been kept open or in storage for long periods.
Any sudden changes in play or hardness in the brake levers are warning signs of problems with the
hydraulic circuits.
Ensure that the brake discs and brake linings have not become contaminated with oil or grease. This
is particularly important after servicing or inspections.
Make sure the brake lines are not twisted or worn.
Prevent accidental entering of water or dust into the circuit.
Wear latex gloves when servicing the hydraulic circuit.
DISC BRAKES
DANGER
The brakes are the parts that most ensure your safety
and for this reason they must always be perfectly working; check them before every trip.
A dirty disc soils the pads.
Dirty pads must be replaced, while dirty discs must be cleaned with a high-quality degreaser.
Perform the maintenance operations reducing by half the indicated frequency if the vehicle is used in
rainy or dusty areas, on uneven surfaces or for racing.
Check brake pads for wear.
When the brake pads wear out, the level of the fluid decreases to automatically compensate for their
wear.
The front brake fluid reservoir is located on the right handlebar, near the front brake lever.
The rear brake fluid reservoir is located under the right fairing.
Do not use the vehicle if the braking system leaks fluid.
GENERAL INFORMATION
1 - 9