JLG 10MSP Service And Maintenance Manual page 48

SECTION 6 - TROUBLESHOO SECTION 6 - TROUBLESHOOTING
Code 01 - Low Battery Voltage Code 01 - Low Battery Voltage
Check For These Obvious Conditions First: Check For These Obvious Conditions First:
• • Battery cable ends loose or corroded Battery cable ends loose or corroded at battery posts.
• • Charger DC output wires from char Charger DC output wires from charger to batteries damaged or di
S S T T E E P P
1. 1. Does battery charger power up thr Does battery charger power up thr ough diagnostic cycle when plugged in to
an AC outlet? an AC outlet?
Is the Abnormal (RED) LED lit when charger is in charge mode? Is the Abnormal (RED) LED lit when charger is in
2. 2.
T T est Batteries. See Battery Condition est Batteries. See Battery Condition in Section 3 of this Ser
3. 3.
Check Battery Condition. See Battery Condition in Section 3 of this Service Check Battery Condition. See Battery Condition in Section 3 of this Service
4. 4.
Manual. Do the batteries pass condition tests? Manual. Do the batteries pass condition tests?
Code 02 - RESERVED Code 02 - RESERVED
Code 03 - RESERVED Code 03 - RESERVED
6-18 6-18
TING
at battery posts.
ger to batteries damaged or disconnected.
Table 6-6. Code 01 - Low Battery Voltage Table 6-6. Code 01 - Low Battery Voltage
A A C C T T I I O O N N
ough diagnostic cycle when plugged in to
charge mode?
in Section 3 of this Ser vice Manual. vice Manual.
– JLG Lift – – JLG Lift –
sconnected.
S S P P E E C C Y Y E E S S
— — G G o o T T o o S S t t e e p p 2 2
— — G G o o t t o o S S t t e e p p 3 3
— — S S ee B ee Bat atte tery ry/B /Bat atte tery C ry Cha har r - -
ger Servicing - ger Servicing -
Section 3 of this Manual Section 3 of this Manual
— — — —
N N O O
S S e e e e B B a a t t t t e e r r y y / / B B a a t t t t e e r r y y C C h h a a r r - -
ger Servicing - ger Servicing -
Section 3 of this Manual Section 3 of this Manual
C C h h a a r r g g e e B B a a t t t t e e r r i i e e s s U U n n t t i i l l
100% (Green) LED is lit. 100% (Green) LED is lit.
Go to Step 4 Go to Step 4
Replace Battery Replace Battery
R R e e p p l l a a c c e e B B a a t t t t e e r r i i e e s s
as Necessary as Necessary
3121228 3121228