Wexiodisk WD-6 DUPLUS Installation And User Manual page 35

Operating instructions
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
23.
In the following chapter, figures are given in brackets to clarify what needs to be
done. These numbers refer to image and list above.
WD-6 DUPLUS
Display for temperature during operation. Together with display (4), it
shows error messages.
Final rinse indicator. The symbol is lit while the machine is filling up, during
the final rinse phase and when the cleaning programme is run after a
completed washing cycle. The symbol flashes if the hood is opened during
the washing cycle or if the final rinse water has not reached the correct
rinse temperature when the rinsing phase is due to start. The machine
continues washing until the correct rinse temperature has been reached.
Symbol for washing function. After the machine is started, the symbol lights
up when the tank is full. The symbol flashes if the water level in the tank is
too low.
Display for programme. The remaining washing time is shown while the
programme is running.
Button for closing or opening the hood. (On machines with an automatic
hood.)
Button for washing programme 1. If the machine has a drain pump, P1 is
used to start the drain pump and empty the tank after washing.
Button for washing programme 2.
Button for washing programme 3. When the machine is in shut-off mode,
P3 is used to start internal rinsing when the cleaning programme is used to
clean the machine.
Button to switch the power on or off. This button is also used to reset
alarms, and to move to service mode. In service mode, the operator can
change the washing temperature and time for the different programmes.
Washing and rinsing arm
Wash nozzle
Autostart switch (optional: if the machine has this option, the hood is closed
automatically when a basket is loaded into the machine.)
Tank for recirculating rinse water
Wash tank
Filter for recirculating rinse
Pump filter
Drain filter (on machines with a drain pump)
Rubber sleeve
Level pipe (if the machine is connected to a WD-PRM6 pre-rinse machine,
there will be no level pipe. This will then be replaced with a bottom filter).
Filter for recirculating rinse
Tank filter and cover plates
Rinse nozzle
Hinged basket conveyor
31
Rev. 4.0 (202202)