Table of Contents
Advertisement
STANDARD UNIT (REMOTE REQUIRES CONNECTION TO A REMOTE CARBONATOR)
CONT' D
Trouble
DISPENSED PRODUCT
PRODUCES FOAM AS IT
LEAVES DISPENSING VALVE.
(cont' d)
NO PRODUCT DISPENSED.
ONLY CARBONATED WATER
DISPENSED.
ONLY SYRUP DISPENSED.
Probable Cause
E.
Tapered gasket inside
carbonated water line swivel
nut connector distorted
restricting carbonated water
flow.
F.
Dirty water supply.
NOTE: If water supply is dirty, be sure to flush lines and carbonator
completely. It may be necessary to remove lines to carbonator tank,
invert tank, and flush tank and all inlet lines to remove any foreign
particles or dirt.
A.
Dispensing valves keyed
lock-out switch in " OFF"
position.
B.
No electrical power to Unit.
C.
Disconnected dispensing
valves power cord.
D.
Disconnected or broken wiring
to dispensing valve.
E.
Inoperative transformer or
valve solenoids.
A.
Out of syrup.
B.
Inoperable dispensing valve.
C.
Dispensing valve syrup flow
control not properly adjusted.
D.
Dispensing valve syrup flow
control or syrup lines
restricted.
A.
Water inlet supply line shutoff
valve closed.
B.
Carbonator power cord
unplugged from electrical
outlet.
C.
Carbonator CO
regulator not
2
properly adjusted.
45
Remedy
E.
Replace tapered gasket. Make
sure it is properly seated.
F.
Check water filter. Replace
cartridge (see NOTE).
A.
Place keyed lock-out switch in
" ON"position.
B.
Plug in Unit power cord or check
for blown power fuse or tripped
circuit breaker.
C.
Connect dispensing valves power
cord.
D.
Connect or replace wiring.
E.
Replace inoperative part.
A.
Replenish syrup supply as
instructed.
B.
Repair dispensing valve.
C.
Adjust dispensing valve syrup
flow control (Water-to-Syrup
" Ratio" ) as instructed.
D.
Sanitize syrup system as
instructed.
A.
Open water inlet supply line
shutoff valve.
B.
Plug carbonator power cord into
electrical outlet.
C.
Adjust carbonator CO
as instructed.
regulator
2
318832000
Advertisement
Table of Contents
