Bomag BW 213 D-4 Operating Instructions, Maintenance Instructions page 97

6.2 Engine
Faults Possible cause
The engine Starter defective or pinion not engaging
does not start
Fuel tank empty
Temperature below starting limit
Fuel filter clogged, in winter due to paraf-
fin separation.
Fuel lines leaking
Battery discharged or not connected
Injection valves or injection pump defec-
tive
The engine Battery power too low, battery clamps
starts poorly and loose or oxidized, causing the starter to
works irregularly turn too slowly
with poor power
Especially during winter: the use of too
viscous engine oil
Fuel supply restricted, in winter fuel sys-
tem clogged due to paraffin separation
Incorrect valve clearance
Injection valve defective
Injection lines leaking
Turbo charger defective
Dry air filter dirty
Excessive play in the throttle cable
BW 213 D-4
Remedy
Have examined by a specialist
Fill and bleed the tank
Use winter fuel and engine oil acc. to the
ambient temperature.
Change the filter. use winter fuel
Check all line connections for leakages
and tighten the fittings.
Tighten the pole clamps, check the cable
connections
Have examined by a specialist
Have the battery checked, clean the ter-
minal clamps, tighten them and cover
them with acid free grease
Use engine oil suitable for the ambient
temperature
Change the fuel filter. Check the line con-
nections for leaks and tighten the fittings.
Use winter fuel in the cold season.
Adjust the valve clearance
Have examined by a specialist
Check the lines for leakages
Have examined by a specialist
clean, replace if necessary
Adjust the throttle cable, change it if nec-
essary
B O M A G
T r o u b l e s h o o t i n g
9 7