Maintenance Checks; Weekly; Monthly; When Cleaning The Chimney System - Pacific energy Alderlea T5 LE Insert Installation And Operating Instructions Manual

Check the following parts for damage such as cracks, excessive corrosion, burned out sections and
excessive warping: (See website for descriptions and more detail)

Weekly:

• Firebrick - Visual, for cracking.
• Door Gasket - sagging, placement, damage.

Monthly

•

Baffle.

• Brick rail tabs and brick rails.
• Air riser tube in the back of the firebox.
• Back side of airwash chamber.
• Baffle locking pin.
• Boost tube cover.
• It is recommended to inspect the liner and connector monthly and to have the liner cleaned
annually or more frequently if required.

When Cleaning the Chimney System:

• Top baffle board/blanket.
• Top heat shield and mounting bolt.
• Baffle Gasket.
• Brick Rails.
• Manifold.

Blower:

• The blowers should be cleaned out a minimum every six months by using a vacuum on the blower
intakes to remove any dust and debris. See "Fan Speed Controller Relocation" section on page 12,
steps 1 & 2, for how to remove the panels and access the blowers.
Baffle:
• Some warping of the baffle is normal (up to 1/4" or 6.5mm). Replace if the baffle has permanent warping
greater than this or has cracking or breakage.
• Please contact your Dealer if you experience any of the damage listed above. Continuing to operate your
stove with broken parts may accelerate damage to other parts and may void your warranty.
DO NOT OPERATE WITH BAFFLE ASSEMBLY OR INSULATION REMOVED.

Removal

Remove retaining pin at the back top of the firebox, just under the baffle. Lift baffle up and pull forward to
disconnect from the supply tube. Tilt baffle sideways to drop down and remove from firebox. Inspect gasket
between baffle and supply tube. If necessary, replace with gasket part number 80000365, available from your
Pacific Energy dealer. Re-install baffle assembly in reverse order. The two side pieces of insulation must be
tight against the side rails.
100003038

Maintenance Checks

Baffle Removal

10
ALT5 LE Insert 230819-32