INTRODUCTION.
This PIPER AIRCRAFT Maintenance Manual is prepared in accordance with the GAMA (General Aviation
Manufacturers Association) format. This maintenance manual is divided into various Groups which enable a
broad separation of contents (Chapters) within each group.
The various Chapters are broken down into major systems such as Electrical Power, Flight Controls, Fuel,
Landing Gear, etc. The System/Chapters are arranged more or less alphabetically rather than by precedence or
importance. All System/Chapters are assigned a number, which becomes the first element of a standardized
numbering system. Thus the element "32" of the number series 32-00-00 refers to the System/Chapter on
"Landing Gear". All information pertaining to the landing gear will be covered in this System/Chapter.
The major System/Chapters are then broken down into Sub-System/Sections. These sections are identified by
the second element of the standardized numbering system. The number "40" of the basic number series 32-40-00
is for the "Wheels and Brakes" portion of the landing gear.
The individual units within a Sub-System/Section may be identified by a third element of the standardized
numbering system, such as 32-40-01. This number could be assigned by the manufacturer to fit the coverage
requirements of the publication.
Example:
CHAPTER/SYSTEM
LANDING GEAR
This manual does not contain hardware callouts for installation. Hardware callouts are only indicated where a
special application is required. To confirm the correct hardware used, refer to the PA-44 Parts Catalog P/N 761
663, and FAR 43 for proper utilization.
WARNINGS, CAUTIONS, and NOTES are used throughout this manual to emphasize important information.
O P E R ATING PROCEDURES, PRACTICES, ETC., WHICH MAY RESULT IN
PERSONAL INJURY OR LOSS OF LIFE IF NOT CAREFULLY FOLLOWED.
O P E R ATING PROCEDURES, PRACTICES, ETC., WHICH IF NOT
STRICTLY OBSERVED MAY RESULT IN DAMAGE TO EQUIPMENT.
An operating procedure, condition, etc., which is essential to emphasize.
PIPER AIRCRAFT
PA - 4 4 - 1 8 0 / 1 8 0 T
AIRPLANE MAINTENANCE MANUAL
32-40-01
— WARNING —
— CAUTION —
— Note —
1A2
SUB-SYSTEMS
WHEELS AND BRAKES
INDIVIDUAL UNITS
NOSE WHEEL REMOVAL
Revised: May 15, 1989
I n t ro d u c t i o n
Page -1