Piper SEMINOLE PA-44-180 Manuals

Manuals and User Guides for Piper SEMINOLE PA-44-180. We have 4 Piper SEMINOLE PA-44-180 manuals available for free PDF download: Maintenance Manual, Information Manual, Pilot Operating Handbook

Piper SEMINOLE PA-44-180 Maintenance Manual (882 pages)

Brand: Piper | Category: Tools | Size: 17 MB

Gama System/Chapter Index Guide
7
Table of Contents
9
List of Illustrations
9
Figure no
10
Airworthiness Limitations
19
Subject Grid no
22
Time Limits/Maintenance Checks
22
Chapter 5 -Time Limits/Maintenance Checks

24
- Inspection Requirements 1A24
  24
- Preflight Checks 1A24
  24
- Overlimits Inspection 1A24
  24
  - Engine Group Inspections
    25
  - Periodic Inspections 1B1 a
    25
  - Propeller Group Inspections
    25
  - Scheduled Maintenance Checks 1B1 9R
    25
    
    Cabin Group Inspections
    29
    
    Turbocharger Group Inspections
    29
    
    Fuselage and Empennage Group Inspections
    30
    
    Wing Group Inspections
    31
    
    Landing Gear Group Inspections
    32
    
    Operational Inspection
    33
    
    Notes on Periodic Inspections
    35
  - Programmed Inspection 1B13
    37
  - Special Inspections as Required Upon Condition 1B13
    37
  - Unscheduled Maintenance Checks - Special Inspections as Required
    37
  - Dimensions and Areas
    39
  - Leading Particulars and Principle Dimensions
    40
  - Airplane Views and Dimensions
    43
  - Station Reference Lines
    44
  - Access and Inspection Provisions
    45
  - Serial Number Plate
    45
  - Access Plates and Panels Diagram
    46
  - Lifting and Shoring
    50
  - Jacking
    52
  - Leveling and Weghing
    54
  - Leveling Airplane
    56
  - Weighing
    57
  - Towing and Taxiing
    59
  - Parking and Mooring
    63
  - Locking Airplane
    64
  - Placards and Markings Table
    67
  - Placards and Decals Diagram
    68
  - Servicing
    71
  - Service Points
    73
  - Replenishing Fuel System
    74
  - Filling Fuel Tanks
    74
  - Draining Fuel System
    74
  - Oil System
    74
  - Draining Oil Sump
    75
  - Filling Oil Sump
    75
  - Oil Screen (Suction)
    75
  - Recommendations for Changing Oil
    75
  - Oil Filter (Full Flow)
    76
  - Scheduled Servicing
    76
  - Landing Gear Servicing
    76
  - Servicing Oleo Struts
    76
  - Filling Nose Gear Oleo Strut
    77
  - Filling Main Gear Oleo Struts
    78
  - Inflating Oleo Struts
    79
  - Servicing Steering Bungee
    79
  - Brake System
    79
  - Filling Brake System Reservoir
    79
  - Draining Brake System
    80
  - Tires
    80
  - Tire Balance
    80
  - Hydraulic System
    81
  - Hydraulic Pump/Reservoir
    81
  - Battery
    81
  - Removal of Induction Air Filter
    81
  - Service Instructions - Air Filter Inspection and Replacement
    82
  - Installation of Air Filter
    82
  - Engine Compartments Cleaning
    82
  - Landing Gear Cleaning
    83
  - Exterior Surfaces Cleaning
    83
  - Windshield and Windows Cleaning
    84
  - Headliner, Side Panels and Seats Cleaning
    84
  - Carpets Cleaning
    84
  - Lubrication Instructions
    85
  - Application of Oil
    85
  - Application of Grease
    85
  - Lubrication Chart (Landing Gear, Main)
    86
  - Lubrication Chart (Landing Gear, Nose)
    88
  - Lubrication Chart (Control System)
    90
  - Lubrication Chart (Cabin Door, Baggage Door & Seats)
    92
  - Lubrication Chart (Power Plant & Propeller)
    95
  - Thread Lubricants
    97
  - Standard Practices/Airframe
    99
- Method of Installing Rod End Bearings 1E5
  99
  - Torque Wrenches
    100
  - Torque Wrench Formula
    100
  - Method of Installing Rod End Bearings
    101
  - Cherrylock Rivet Removal
    102
  - Maximum Distance between Supports for Fluid Tubing
    103
  - Identification of Fluid Lines
    103
  - Aircraft Finish Care/Cleaning
    105
  - Exterior Surfaces Cleaning
    105
  - Windshield/Windows Cleaning
    105
  - Headlinder, Side Panels and Seats Cleaning
    105
  - Carpets
    106
  - Cleaning the Engine Compartment
    106
  - Fuel System Cleaning
    106
  - Landing Gear Cleaning
    107
  - Environmental System
    109
  - Environmental System Description and Principles of Operation
    112
  - Environmental System Troubleshooting
    113
  - Janitrol Heater Troubles
    113
  - Cabin Vent System
    116
  - Overhead Vent Blower
    116
  - Removal of Blower Assembly
    116
  - Dismantling of Blower Assembly
    117
  - Rebuilding of Blower Assembly
    117
  - Installation of Blower Assembly
    117
  - Blower System Wire Color Codes
    118
  - Heating System Operational Test
    118
  - Description of Heater and Basic Components
    119
  - Spark-Spray Ignition
    119
  - Cabin Environmental System Installation
    120
  - Heater and Combustion Air Blower Assembly
    121
  - Fuel Regulator and Shutoff Valve
    122
  - Duct Switch
    122
  - Cumbustion Air Blower/Ventilating Air Blower
    122
  - Diagramatic Cutaway of Heater to Show Whirling Flame Action
    122
  - Top View - Duct Switch
    123
  - Heater Operating Controls
    124
  - Heater Operating Procedure
    124
  - Intake Valve and Switches View
    124
  - Heater and Heater Components Inspection
    125
  - Removal of Heater
    126
  - Installation of Heater
    127
  - Heater Electrical System Checks
    127
  - Heater Electrical System Wiring Diagram
    128
  - Primary Power Circuit (Heater)
    129
  - Vent Blower Power Circuit Check
    130
  - Starting Power Circuit (Heater)
    130
  - Heater Power Circuit Check
    131
  - Combustion Air Blower Maintenance
    131
  - Replacing Motor Brushes
    132
  - Spark Plug Fixture
    132
  - Wiring - Test Setup
    132
  - Spark Plug Removal
    133
  - Spark Plug Gap Adjustment
    133
  - Spark Plug Inspection and Servicing
    134
  - Ignition Unit Removal and Installation
    135
  - Spark Plug Installation
    135
  - Ignition Unit Testing
    136
  - Vibrator Removal and Installation
    137
  - Ignition Unit Assembly View
    137
  - Ignition Unit Inspection
    138
  - Cycling Switch and Limit (Overheat) Switch Removal and Installation
    138
  - Combustion Air Pressure Switch Removal and Installation
    139
  - Fuel Regulator Removal
    139
  - Fuel Regulator Adjustment
    139
  - Fuel Regulator Installation
    140
  - Heater Fuel Pump Removal
    140
  - Heater Fuel Pump View
    141
  - Pump Disassembly
    141
  - Pump Cleaning
    141
  - Pump Repair and Inspection
    142
  - Pump Assembly
    142
  - Heater Fuel Pump Installation
    142
  - Duct Switch Removal and Installation
    142
  - Heater Assembly Overhaul
    143
  - Heater Disassembly
    143
  - Combustion Air Blower Assembly Disassembly
    144
  - Heater Components Cleaning
    144
  - Design for Seal Plates, Plugs, Caps for Combustion Tube Leakage Test
    145
  - Test Setup for Combustion Air Pressure Switch
    145
  - Combustion Tube Assembly Cleaning and Assembly
    146
  - Remaining Components Inspection
    147
  - Check Ventilating Air and Combustion Air Motors
    148
  - Test the Combustion Tube Assembly for Leaks
    148
  - Test the Combustion Air Pressure Switch
    149
  - Test the Fuel Line and Fuel Line Shroud Tube for Leaks
    149
  - Spray Test the Nozzle
    149
  - Exploded View of Heater Assembly
    150
  - Combustion Tube Assembly Repair
    151
  - Heater Reassembly
    151
  - Combustion Air Blower and Motor Assembly Exploded View
    152
  - Combustion Air Blower Assembly Reassembly
    153
  - Suggested Setup of Heater Operation
    154
  - Wiring Connections for Heater Operation Test
    154
  - Test Procedure - Equipment Required/Operational Test on Test Bench
    155
  - Fuel Nozzle Orifice Inspection
    156
  - Heater Hourmeter Removal
    157
  - Heater Hourmeter Installation
    157
  - Spark Plug Gap Adjustment Tool Diagram
    157
  - Heater Hourmeter Installation Diagram
    158
  - Air Conditioning System Description and Principles of Operation
    159
  - Air Conditioning System Troubleshooting
    159
  - Air Conditioning System Installation Diagram
    165
  - Temperature Pressure Chart
    166
  - Air Conditioning System Malfunction Detection
    167
  - Servicing Air Conditioning System
    168
  - Aluminium Tubing Torque Chart
    169
  - Service Values
    169
  - Test Gauge and Manifold Set
    170
  - Manifold Set Operation
    171
  - Leak Detection
    172
  - Duscharging the Air Conditioning System
    173
  - Evacuating the Air Conditioning System
    173
  - Evacuation Hookup Diagram
    174
  - Charging the Air Conditioning System
    175
  - Charging Stand Method
    175
  - Charging Stand View
    176
  - Airplane Compressor Method
    176
  - Charging Hookup Diagram
    177
  - Partial Charge of Air Conditioning System
    178
  - Air Conditioning System Components
    179
  - Compressor Service
    179
  - Compressor Removal
    179
  - Compressor Installation
    179
  - Top Dead Center Casting Mark (Sankyo Compressor)
    180
  - Rotation of Clutch Front Plate (Sankyo Compressor Oil Check)
    180
  - Compressor Oil Level Check
    181
  - Drive Belt Tension Adjustment
    182
  - Receiver-Dehydrator Removal
    182
  - Receiver-Dehydrator Installation
    182
  - Condenser
    182
  - Condenser Installation
    183
  - Condenser Removal and Installation
    184
  - Expansion Valve Removal
    184
  - Expansion Valve Installation
    185
  - Evaporator Assembly
    185
  - Evaporator Assembly Removal
    186
  - Evaporator Assembly Installation
    186
  - Evaporator Blower Motor Wire Codes
    187
  - Pressure Relief Switch
    188
  - Electrical Installation
    188
  - Manifold Pressure Switch
    188
  - Autoflight
    190
  - Communications
    193
  - Emergency Locator Transmitter (ELT)
    194
  - Battery Removal and Installation
    194
  - Communications Components Corporation ELT Schematic
    195
  - Narco ELT 10 Portable Folding Antenna
    196
  - Narco ELT 10 Using Fixed Aircraft Antenna
    196
  - Narco ELT 10 Battery Removal and Installation
    197
  - Narco ELT 10 Emergency Locator Transmitter Schematic
    197
  - Emergency Locator Transmitter Testing
    198
  - ELT 910 Battery Pack View
    199
  - Artex ELT-110 - General Information
    199
  - Artex 110 ELT Battery Removal and Installation
    200
  - Testing the Artex ELT 110 Emergency Locator Transmitter
    201
  - Artex E.L.T. 110 Wiring Schematic
    201
  - Electrical Power
    203
  - Electrical System Description and Operation
    205
  - Electrical System Troubleshooting
    205
  - Alternator Troubleshooting
    206
  - Zero Output Indicated on Ammeter Regardless of RPM
    206
  - Output Indicated on Ammeter Does Not Meet Minimum Values
    207
  - Field Circuit Breaker Trips
    208
  - Output Circuit Defective
    209
  - Excessive Ammeter Fluctuation
    210
  - Battery Troubleshooting
    211
  - Discharged Battery/Battery Life Is Short
    211
  - Cracked Cell Jars
    211
  - Compound on Top of Battery Melts/Electrolyte Runs out of Vent Plugs
    211
  - Excessive Corrosion Inside Container
    212
  - Battery Freezes
    212
  - Battery Polarity Reversed
    212
  - Battery Consumes Excessive Water
    212
  - DC Generation
    213
  - Alternator System
    213
  - Checking Alternator Belt Tension
    214
  - Lamp Bank Load Diagram
    214
  - Battery Box Diagram
    216
  - Charging Circuit Service Procedures
    217
  - Hydrometer Reading and Battery Charge Percent
    217

Piper SEMINOLE PA-44-180 Maintenance Manual (842 pages)

Brand: Piper | Category: Aircrafts | Size: 17 MB

Radar Altimeter
4
Maintenance
7
Time Limits, Maint Checks
7
Table of Contents
10
Assembly I Fl
14
Airworthiness Limitations
18
Airwor-Thiness
19
Maintenance
20
Engine Group
28
Wing Group
32
Landing Gear Group
32
Periodic Inspections
36
Reference Lines
44
Oleo Struts
79
Tire Balance
80
Maintenance
83
Lubrication Chart Landing Gear. Nose
89
Lubrication Chart Cabin Door. Baggage Door
92
Special Instruction
93
Lubrication Chart Control System. Part
94
Lubrication Chart Power Plant and Wrench Formula
96
Standard Practices/ Airframe
98
Maintenance
103
Engine Compartment
106
Fuel System
106
Environmental System
108
Fuel Regulator and Shutoff Valve
109
Troubleshooting
116
Fresh Air
120
Fuel Regulator
122
Combustion Air Blower
122
System Checks
127
H Eater Sw Itc H
130
General Maintenance
131
Spark Plug
133
Removal and Installation
137
Air Pressure Switch
139
Test Procedure
155
Side View
158
Trolbleshooting
159
Pressure Chart
166
Leak Detection
172
Oil Level Check
181
Installation
185
Emergency Locator Transmitter
196
Pilot'sremote Switch
197
Electrical Power
200
Alternator Belt Tension
212
Belt Tension
213
Operation
219
Circuit Operation
223
Flight Controls
226
Troubleshooting
230
Aileron Control
230
Control System
233
Installation
236
Trim Controls
252
Stall Warning
270
Vendor Publications
278
Lifting and Shoring
281
Station References
284
And Decals
284
Chart Control System. Part
284
Cherrylock Rivet Removal
284
Of Aircraft Fluid Lines
284
Cabin Environmental System Installation
284
Duct Switch Valve and Switches Diagram
284
Starting Power Circuit
284
Spark Plug Fixture
284
Test Setup
284
Heater Hourmeter Installation I
285
Condenser Installation Lh
285
Emergency Locator Transmitter Installation
285
ELT Using Fixed Aircraft Antenna (Narco)
285
Electrical Component Location IJ3
285
Correct Method of Installing Rod End Bearing IKS
285
Rudder Controls IK20
285
Rudder Trim Controls I L I
285
Troubleshooting
294
Storage
298
Fuel Cells 2A24 a
298
Removal of Fuel Cells 2A24
298
Installation
298
Fuel Cell Compartment 2B2
300
Molded Nipple Fittings
300
Repair of Fuel Cells
301
Repair Procedures
302
Repair Limitations
302
Repair Patch (Air Cure Method) 2B7
305
Accessory Replacement
305
Defect Repairs of Fuel Cell 2B8
306
Testing Fuel Cells 2B8
306
Locking Fuel Cap 289 a
307
Distribution
308
Cleaning Gascolator 2B10
308
Reassembly of Gascolator
308
Cleaning Fuel System 2Bl3
311
Electric Fuel Pump 2Bl4
312
Indicating
312
Fuel Pressure
314
Troubleshooting
320
Low Pressure
331
Hydraulic Pump Motor
332
Installation
333
Ice and Rain Protection
339
Troublshooting
344
Troubleshooting
346
Hour Inspection
348
Operation
349
Troubleshooting
364
Installation
380
Troubleshooting
390
Wheels and Brakes
397
Assembly of Main Gear Oleo
408
Installation
413
Trunnion Assembly
421
Assembly of Nose Gear Oleo
422
Installation
428
Nose Wheel Assembly
438
Repair of Nose and Main Wheel Assemblies
440
Brake Assembly
442
Brake Valve
446
Installation
450
Position and Warning
452
Landing Gear Limit Switches 2H
452
Limit Switches 2H
452
Switch Location 2H
454
Warning Switch 2H
454
Troubleshooting
460
Strobe Light System
463
Navigation and Pitot/ Static
466
General
469
Description and Operation
469
Flight
469
Rate of Climb Indicator
469
Altimeter
472
3402. Troubleshooting
473
Airspeed Indicator
473
Indicator
473

Piper SEMINOLE PA-44-180 Information Manual (354 pages)

Brand: Piper | Category: Aircrafts | Size: 25 MB

Table of Contents

8
- Issued:july
  3
  - Table of Contents
    8
- Revised para
  10
- Report: Vb
  12
  - Issued: July
    14
Table of Contents

15
- Introduction
  17
- Engine
  19
- Propeller
  19
- Fuel
  20
- Oil
  20
- Baggage Space and Entry Dimensions
  21
- Maximum Weights
  21
- Specific Loading
  21
- Standard Airplane Weights
  21
- Symbols, Abbreviations and Terminology
  23
Table of Contents

29
- Airspeed Limitations
  31
- General
  31
- Airspeed Indicator Markings
  32
- Power Plant Limitations
  33
- Power Plant Instrument Markings
  34
- Center of Gravity Limits
  35
- Flight Load Factors
  35
- Maneuver Limits
  35
- Weight Limits
  35
- Fuel Limitations
  36
- Gyro Suction Limits
  36
- Maximum Seating Configuration
  36
- Revised: June
  36
- Types of Operation
  36
- Placards
  37
- February
  38
Table of Contents

41
Engine Failure During Takeoff (Speed above 75 Kias) (3.9D)

49

Piper SEMINOLE PA-44-180 Pilot Operating Handbook (344 pages)

WITH GARMIN G1000 SYSTEM

Brand: Piper | Category: Aircrafts | Size: 8 MB

General

13
- Table of Contents
  13
- General
  15
- Introduction
  15
- Propeller
  17
- Engine
  17
- Fuel
  18
- Oil
  18
- Baggage Space and Entry Dimensions
  19
- Specific Loading
  19
- Standard Airplane Weights
  19
- Maximum Weights
  19
- G1000 GNSS (GPS/SBAS) Navigation System Equipment Approvals
  20
- Symbols, Abbreviations and Terminology
  22
- General
  22
Section 2 Limitations

29
- Airspeed Limitations
  31
- General
  31
- Airspeed Indicator Markings
  32
- Power Plant Limitations
  33
- POWERPLANT INSTRUMENT Markings
  34
- Systems Limitations
  34
- Center of Gravity Limits
  35
- Flight Load Factors
  35
- Maneuver Limits
  35
- Weight Limits
  35
- Fuel Limitations
  36
- Maximum Seating Configuration
  36
- Types of Operation
  36
- Garmin G1000 Avionics System Limitations
  37
- Aspen Standby Instrument Limitations
  45
- GFC 700 Automatic Flight Control System (AFCS)
  45
- Placards
  46
Section 3 Emergency Procedures

49
- Paragraph Page
  50
- General
  53
- Annunciations and Alerts
  54
- Crew Alerting System (CAS) Messages
  54
- Terminology
  58
- Airspeeds for Safe Operations
  59
- Emergency Procedures Checklist
  59
- Engine Inoperative Procedures
  59
- Engine Securing Procedure (Feathering Procedure)
  59
- Engine Failure During Takeoff (Speed below 75 KIAS or Gear Down)
  60
- Engine Failure During Takeoff (Speed above 75 KIAS)
  61
- Engine Failure During Climb
  63
- Engine Failure During Flight (Speed below VMCA )
  64
- Engine Failure During Flight (Speed above VMCA )
  65
- One Engine Inoperative Landing
  66
- One Engine Inoperative Go-Around
  67
- Inoperative
  68
- Summary of Factors Affecting Single Engine Operations
  68
- Cruising - One Engine Inoperative
  71
- Landing - One Engine Inoperative
  71
- Air Starting Procedure
  72
- Unfeathering Procedure Unfeathering Accumulator Functioning
  72
- Unfeathering Procedure/Starter Assisted
  73
- Engine Roughness
  74
- Engine Indicating System (EIS)
  75
- High Oil/Cylinder Head Temperature
  75
- Oil Pressure
  75
- Fuel Quantity
  76
- Loss of Fuel Flow
  76
- Engine Fire
  77
- Engine Fire During Start
  77
- Engine Fire in Flight
  77
- Electrical Fire
  78
- Landing Gear Unsafe
  78
- Landing Gear Malfunctions
  79
- Electrical Failures
  80
- Single Alternator Failure
  80
- Dual Alternator Failure
  81
- Complete Electrical Failure
  83
- Avionics System Failures
  84
- Emergency Battery Voltage
  84
- PFD Failure
  84
- MFD Failure
  86
- Attitude Heading Reference System (AHRS) Failures
  87
- Air Data Computer (ADC) Failures
  88
- Avionics System Failures (Continued)
  89
- Erroneous Indication or Loss of Engine and Fuel Displays
  89
- Erroneous or Loss of Warning/Caution cas Messages
  90
- Communications (COM1 and COM2) Failure
  91
- Dual GPS Failure
  91
- Automatic Autopilot Disconnect
  93
- Autopilot Malfunction
  93
- Electric Pitch Trim Runaway
  94
- Electric Pitchtrim Failure
  94
- Autopilot Overspeed Recovery
  95
- Autopilot Underspeed Recovery
  95
- Autopilot Out-Of-Trim
  96
- Abnormal Flight Director Mode Transition
  97
- Autopilot Preflight Test Failure
  97
- Loss of Navigation Information
  98
- Cooling Fan Failures
  99
- Pitot Heat Failure
  99
- Hydraulic Pump Failures
  100
- Spin Recovery
  101
- Starter Engaged
  101
- Open Door
  102
- Propeller Overspeed
  102
- Emergency Exit
  103
- Heater Overheat
  103

Piper Categories

Aircrafts Tools Toy Commercial Food Equipment

Oven

More Piper Manuals

Piper SEMINOLE PA-44-180 Manuals

Piper SEMINOLE PA-44-180 Maintenance Manual (882 pages)

Table of Contents

Chapter 5 -Time Limits/Maintenance Checks

Piper SEMINOLE PA-44-180 Maintenance Manual (842 pages)

Table of Contents

Piper SEMINOLE PA-44-180 Information Manual (354 pages)

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Engine Failure During Takeoff (Speed above 75 Kias) (3.9D)

Piper SEMINOLE PA-44-180 Pilot Operating Handbook (344 pages)

Table of Contents

General

Section 2 Limitations

Section 3 Emergency Procedures

Related Products

Piper Categories