Carrier Aero 39MN Series Installation, Start-Up And Service Instructions Manual page 250

START-UP CHECKLIST — CARRIER 39M GAS-FIRED FURNACE RACK ASSEMBLY
NOTE: To avoid injury to personnel and damage to equipment or
property when completing the procedures listed in this start-up
checklist, use good judgment, follow safe practices, and adhere to
the safety considerations/information as outlined in preceding sec-
tions of this Installation Instruction document.
I. PRELIMINARY INFORMATION
FURNACE SERIAL NO(S). __________________________________
CARRIER MODEL NO. _____________________________________
SERIAL NO. ______________________________________________
START-UP DATE __________________________________________
START-UP CONTRACTOR __________________________________
TECHNICIAN NAME _______________________________________
PHONE _________________________________________________
TYPE OF GAS ___________________________________________
GAS PRESSURE AT INLET (BURNERS OFF) _____________________________________________________________ in. wg
SUPPLY VOLTAGE AT JUNCTION BOX ___________________________________________________________________ vac
II. OPERATING SET-UP
OPERATING SET-UP DATA
Gas Press. at Supply Inlet
Gas Input Rate
CO in Flue Gas
2
CO in Flue Gas
Flue Gas Temp at Discharge
Temperature Rise
III. OPERATION CHECKLIST
All gas lines and connections checked for leaks (Pg 172) (Y/N) _____
Adequate combustion air (Pg 171)
Condensate drain lines installed(Pg 170)
Any system deficiencies noted
DESCRIBE:
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________
SIGNATURE:
© Carrier Corporation 2018
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
Catalog No. 04-53390022-01
SINGLE UNIT
LOW FIRE (0V DC)
___________in. wg
____________Btuh
Measurements at Common Header Discharge
_______________%
_____________ppm
______________°F
______________°F
(Y/N) _____
(Y/N) _____
(Y/N) _____
Printed in U.S.A. Form 39M-20SI
2 RACKED FURNACES IN
SERIES — SECONDARY
HIGH FIRE (10V DC) HIGH FIRE (10V DC)
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
_______________________________
DATE:
Pg CL-6 718 1-18
SYSTEM
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
Replaces: 39M-18SI