Carrier Aero 39MN Series Installation, Start-Up And Service Instructions Manual page 249

START-UP CHECKLIST — CARRIER 39M GAS-FIRED DUCT FURNACE
NOTE: To avoid injury to personnel and damage to equipment or
property when completing the procedures listed in this start-up
checklist, use good judgment, follow safe practices, and adhere to
the safety considerations/information as outlined in preceding sec-
tions of this Installation Instruction document.
I. PRELIMINARY INFORMATION
FURNACE SERIAL NO(S) __________________________________________________
CARRIER MODEL NO._____________________________________________________
SERIAL NO. _____________________________________________________________
START-UP DATE _________________________________________________________
START-UP CONTRACTOR _________________________________________________
TECHNICIAN NAME ______________________________________________________
PHONE ________________________________________________________________
TYPE OF GAS ___________________________________________________________
GAS PRESSURE AT INLET (BURNERS OFF)_____________________________________________________________ in. wg
SUPPLY VOLTAGE AT JUNCTION BOX __________________________________________________________________ vac
II. OPERATING SET-UP
OPERATING SET-UP DATA
Gas Press. at Train Inlet
Gas Press. at Burner Manifold
Gas Input Rate
CO in Flue Gas
2
CO in Flue Gas
Flue Gas Temp at Discharge
Temperature Rise
III. OPERATION CHECKLIST
All gas lines and connections checked for leaks (Pg 167) (Y/N) _____
Adequate combustion air (Pg 163)
Condensate drain lines installed(Pg 163)
Any system deficiencies noted
DESCRIBE:
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________________________________________________________
_______________________________________________________
SIGNATURE:
SINGLE UNIT
LOW FIRE (0V DC)
___________in. wg
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
(Y/N) _____
(Y/N) _____
(Y/N) _____
CL-5
HIGH FIRE (10V DC)
___________in. wg
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F
_______________________________
DATE:
2 UNITS IN SERIES —
SECONDARY HEATER
HIGH FIRE (10V DC)
___________in. wg
___________in. wg
____________Btuh
_______________%
_____________ppm
______________°F
______________°F