Genie S-40 Service Manual page 11

October 2014
Section 3 Scheduled Maintenance Procedures, continued
Checklist E Procedures
E-1
E-2
E-3
E-4
E-5
E-6
E-7
E-8
E-9
Section 4 Repair Procedures
Introduction ............................................................................................................ 4 - 1
Platform Controls
1-1
1-2
Platform Components
2-1
2-2
2-3
Jib Boom Components
3-1
3-2
Boom Components
4-1
4-2
4-3
4-4
4-5
Part No. 826364
Test or Replace the Hydraulic Oil ............................................................... 3 - 55
Grease the Steer Axle Wheel Bearings, 2WD Models ................................ 3 - 57
Perform Engine Maintenance - Perkins Models .......................................... 3 - 58
Perform Engine Maintenance - Deutz Models ............................................. 3 - 59
Perform Engine Maintenance - Deutz Models ............................................. 3 - 59
Perform Engine Maintenance - Perkins Models .......................................... 3 - 60
Perform Engine Maintenance - Perkins 404D-22 Models ............................ 3 - 60
Perform Engine Maintenance - Deutz Models ............................................. 3 - 61
Perform Engine Maintenance - Perkins 404F-22 Models ............................ 3 - 61
ALC-500 Circuit Board .................................................................................. 4 - 2
Joysticks ..................................................................................................... 4 - 3
Platform Leveling Slave Cylinder .................................................................. 4 - 8
Platform Rotator ........................................................................................... 4 - 9
Platform Overload System ......................................................................... 4 - 11
Jib Boom .................................................................................................... 4 - 14
Jib Boom Lift Cylinder ................................................................................ 4 - 15
Cable Track ................................................................................................ 4 - 16
Boom ......................................................................................................... 4 - 18
Boom Lift Cylinder ...................................................................................... 4 - 21
Boom Extension Cylinder ........................................................................... 4 - 22
Platform Leveling Master Cylinder .............................................................. 4 - 23
S-40 • S-45 • S-40 TRAX • S-45 TRAX
Section 1 • Table of Contents
TABLE OF CONTENTS
xi