Test Procedures; Index Of Test Procedures - Club Car 2005 FE290 Maintenance Service Supplement

TROUBLESHOOTING AND ELECTRICAL SYSTEM
ELECTRICAL SYSTEM
The electrical system on the gasoline vehicle is 12 volts DC with negative (–) ground to frame, and consists
of seven circuits that are easily identified:
• Starter Circuit
• Generator Circuit
• Engine Ignition Circuit
• Engine Kill Circuit
• Reverse Buzzer Circuit
• Low Oil Warning Light Circuit
• Neutral Lockout Circuit
Utility vehicles (Turf 1, Carryall 1, and Villager 4) have two additional circuits:
• Fuel Gauge and Sending Unit Circuit
• Hour Meter Circuit
Utility vehicles (Turf 1, Carryall 1, and Villager 4) have a combination fuel gauge/hour meter.
Recognizing and understanding the function of each of these circuits will help to quickly isolate the source of
an electrical problem. Use the appropriate test procedure to correct the electrical problem. See Test Proce-
dures on page 11-7.

TEST PROCEDURES

INDEX OF TEST PROCEDURES

1. Battery
2. Fuse
3. Ground Cables
4. Key Switch (Starter Circuit)
5. Accelerator Pedal Limit Switch
6. Solenoid
7. Neutral Lockout Limit Switch
8. Starter/Generator (Starter Function)
9. Wire Continuity
10. Starter/Generator (Generator Function)
11. Voltage Regulator
12. Disconnected Kill Wire
13. Ignition Spark
14. RPM Limiter
15. Ignition Coil
16. Kill Limit Switch
17. Key Switch (Engine Kill Circuit)
2005 FE290 Gasoline Vehicle Maintenance and Service Supplement
11
Electrical System
A
Page 11-7