Fuel Lines - Club Car 2005 FE290 Maintenance Service Supplement

FUEL SYSTEM
TO CARBURETOR

FUEL LINES

See General Warning, Section 10, Page 10-1.
The fuel lines must be properly routed, and all hose clamps must be tight. The fuel lines should be kept clean.
See following WARNING.
ý
WARNING
• Make sure fuel lines are the right length and are properly routed. Failure to heed this warning
could result in damage to fuel lines and fire.
Fuel line no. 1 runs directly from the fuel tank to the primary fuel filter (17). The primary fuel filter has an arrow
indicating fuel flow direction (Figure 14-11, Page 14-18).
Fuel line no. 2 runs directly from the primary fuel filter to the fuel inlet of the fuel pump.
Fuel line no. 3 runs directly from the fuel outlet of the fuel pump to the secondary fuel filter (Figure 14-11,
Page 14-18). The secondary fuel filter has an arrow indicating fuel flow direction and is identical to the primary
fuel filter.
Fuel line no. 4 runs from the outlet of the secondary fuel filter to the carburetor (Figure 14-11, Page 14-18).
Small spring steel band clamps are used on all hose connections except at the carburetor. A screw band
clamp (16) should be used at the carburetor (Figure 14-11, Page 14-18).
2005 FE290 Gasoline Vehicle Maintenance and Service Supplement
VENT TUBES
Figure 14-15 Fuel Tank
Fuel Lines
VENT
SHUT-OFF
VALVE
Page 14-25
14
A