Headlight Bulbs - Buell XB9R 2003 Service Manual

Hide thumbs Also See for XB9R 2003:

Table of Contents

The XB9R uses dual headlights with replaceable bulbs. High

beam headlight is located on the right side of vehicle.

High beam headlight turns on and off with headlight

Low beam headlight is located on the left side of vehicle.

RUN switch must be on for low beam to be on.

Adjustment of individual headlight projection is accom-

plished by adjusting two screws located in the headlight

For information on headlight housing and bracket disassem-

bly/assembly see

2.25 HEADLIGHT SUPPORT BRACKET.

HEADLIGHT BULBS

To protect against accidental start-up of vehicle, discon-

nect the negative battery cable before proceeding. Inade-

quate safety precautions could result in death or serious

Disconnect negative battery cable.

The bulb contains Halogen gas under pressure. Handle

bulb carefully and wear eye protection. Failure to follow

adequate safety precautions could result in minor or

moderate injury.

Never touch the bulb with your ﬁngers. Fingerprints will

etch the glass and cause the bulb to fail. Always wrap the

bulb in paper or a clean, dry cloth during handling.

Figure 7-43.

Disconnect headlight connection (1).

Release wire retaining latch (5) from headlight housing

Pull bulb housing from headlight housing.

Headlight connection

Ground connection

Headlight bulb

Wire retaining latch

Figure 7-43. Headlight Bulb

2003 Buell XB9R: Electrical