Battery Cables; Negative Battery Cable - Buell XB9R 2003 Service Manual

HOME

BATTERY CABLES

REMOVAL
1 1
WARNING WARNING
To protect against shock and accidental start-up of vehi-
cle, disconnect the negative battery cable before pro-
ceeding. Inadequate safety precautions could result in
death or serious injury.
1 1
WARNING WARNING
Always disconnect the negative battery cable first. If the
positive cable should contact ground with the negative
cable installed, the resulting sparks may cause a battery
explosion which could result in death or serious injury.
1. See Figure 7-35. Disconnect negative and positive
cables from battery, negative cable first.
a. Remove fastener holding negative cable to negative
terminal.
b. Remove fastener holding positive cable to positive
battery terminal.
2. See Figure 7-36. Remove fastener to detach negative
battery cable from frame.
3. See Figure 7-37. Remove protective rubber boot from
starter fastener. Remove fastener with washer to detach
positive battery cable from starter.
INSTALLATION
1. Clean cable connectors and battery terminals using a
wire brush or sandpaper to remove any oxidation.
1 1
WARNING WARNING
Always connect positive battery cable first. If the positive
cable should contact ground with the negative cable
installed, the resulting sparks may cause a battery explo-
sion which could result in death or serious injury.
CAUTION
Connect cables to correct terminals of battery or serious
damage to motorcycle electrical system will occur.
2. Connect cables to battery.
a. See Figure 7-35. Positive battery cable runs from
starter to positive battery terminal.
b. Connect positive cable to positive (+) battery termi-
nal using fastener.
c. Connect negative cable to negative (-) battery termi-
nal using fastener.
d. Tighten terminal fasteners to 72-96 in-lbs (8-11
Nm).
6
5
4
(+)
3
2
2
1. Battery strap bracket
2. Battery pad (4)
3. Battery
4. Battery boot
5. Positive cable
6. Battery strap
7. Negative cable
8. To frame
9. To starter
Figure 7-35. Battery
8442
Figure 7-36. Negative Battery Cable
2003 Buell XB9R: Electrical
7.9
b1005x7x
7
(-)
8
9
1
7-29