Maintenance After First 50 Hours And Every 2 Months; Drain The Fuel Filter - FNM HPE 300 Owner's Manual

Marine Diesel Engines
Fuel filter drain. (p. 60).
Change the gearbox oil (Tecnhodrive TMC® after first 50 hours-ZF® after first
25 hours ) Refer to the manufacturer's indications.
Lubricate the propeller shaft and retorque the propeller nut.
Engine oil change ( first change after first 30 hrs)
Check for engines anodes corrosion status (p. 61).
Check the belts and tighteners status (p 62).
Verify the engine alignment and retorque the engine mounts.
Verify the bolts tightening torque.
Verify the electrical connection and plant.
Check the transmission fluids (page 55).
Clean the air filter (page 63).
Check the sea water pump impeller (page 63).
Clean the sea water circuits by flushing fresh water.
To drain the fuel filter:
1. Remove the water in fuel presence sensor plug from under the filter.
2. Use a little clean container to collect the fuel that will come out, about 0,5 l.
Don't smoke during the operations.
Unscrew the drain cap under the filter ad wait that fuel comes out. Close when you notice that the
3.
fuel is clean and free of impurities or contamination of water.
The fuels such as waste oils are highly polluting. Respect the environment.
ENG rel. 1/11
O
WNER

Maintenance after first 50 hours and every 2 months

AFTER THE FIRST 50 HOURS OR 2 MONTHS
ACTIVITY

Drain the fuel filter

www.fnm-marine.com
'
M
S ANUAL
Engine maintenance
HPE300
Achievable
Achievable
by
by owner
service
* *
*
*
*
* *
* *
*
*
*
*
* *
* *
* *
60