FNM HPE 300 Owner's Manual page 24

Marine Diesel Engines
- Disconnect the electrical connections. Push the red stop button on the ECU box .
-
Clean the engine metal part and spray the engine metal parts and the engine leverages with a
protective/unlocking spray to prevent rust. FNM
- Grease the starter pinion and the mechanical connections (grooved joints, etc.)
- Dismount the belts and store them preventing their deformation.
- Disconnect the fuel line (inlet and outlet).
- Spray the electrical connections with electrical connections protective spray.
- Store the engine in a well aerated place avoiding humidity and steam to prevent rust forming.
-
For long storage of fuel in tank, FNM® advises to use Bardahl® DAB additive or IOSSO® Diesel
fuel antibacterial to prevent the proliferation of algae and deposits.
-
For fuel winter storage, FNM
FNM® advises use of Bardahl Diesel Antifreeze
ATTENTION!
Take care of the engine storage room out of the boat or maintain the boat engine room dry and free from
salt vapor.
-
After a period of inactivity, it is necessary to carry out few maintenance interventions before
starting the engine again to ensure its efficiency and duration.
-
Verify the battery charge level conditions. Make sure that the battery voltage is greater than 12
Volt.
-
-Make sure that the electric contacts are intact and properly grease with basic grease. Assure the
correct electrical connections.
-
Carry out the engine electronic diagnosis at the first starting after a long period of inactivity.
- -Check the oil level conditions, and if necessary, top up or replace with synthetic oil SAE 5 W 40
as advised.
-
Verify the clogging level and if necessary replace the oil filter.
- Check the coolant level and if necessary top up. Drain the sea water circuits.
- Verify and if necessary replace/clean the fuel filter.
- Clean the air filter.
- Verify the belts and tighteners status.
- Verify the integrity of the sea water pump impeller.
ENG rel. 1/11
'
O M
WNER S
advises to use Bardahl
®
advises (for very cold storage) to use diesel fuel antifreeze additive.
®
.
www.fnm-marine.com
ANUAL
K9 spray
®
General Information
HPE 300
.
24