Checking The Fuel Pressure - KTM 350 EXC-F EU Repair Manual

12 FUEL TANK, SEAT, TRIM
12.10

Checking the fuel pressure

Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
The fuel in the fuel tank expands when warm and may emerge if overfilled. Follow the instructions on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Fuel must not come into contact with the skin, eyes, or clothing. Do not breathe in the fuel vapors. If contact occurs with
the eyes, rinse with water immediately and contact a physician. Immediately clean contaminated areas on the skin with
soap and water. If fuel is swallowed, contact a physician immediately. Change clothing that is contaminated with fuel.
Store fuel properly in a suitable canister and keep away from children.
–
Position the fuel pump.
–
Mount fuel connection
Guideline
Fuel connection on fuel pump
–
Mount and tighten nut
Guideline
Nut, fuel pump fixation
305313-10
–
Tighten fuel connection
Guideline
Fuel connection on fuel pump
–
Mount and tighten screws
Guideline
Screw, fuel pump
305314-10
Condition
The fuel tank is full.
Ensure that the battery voltage does not drop below 12.5 V.
The diagnostics tool is disconnected.
–
Thoroughly clean the plug-in connection of the fuel line using compressed air.
Info
Under no circumstances should dirt enter into the fuel line. Dirt in the fuel
line clogs the injection valve.
–
Press on the small metal plate and disconnect fuel hose connection
Info
Remaining fuel may flow out of the fuel hose.
G01353-10

with the gasket but do not tighten yet.
M8

with the gasket.
M12

.
M8

.
EJOT PT
10 Nm (7.4 lbf ft)
15 Nm
(11.1 lbf ft)
10 Nm (7.4 lbf ft)
® 3 Nm (2.2 lbf ft)

.
96