DAELIM S2-250 Service Manual page 68

6. COOLING SYSTEM
INFORMATION· · · · 6-1
SERVICE
TROUBLESHOOTING· · · · · · · · 6-2
COOLANT· · · · · · · · · · · · · · · · · · · · 6-3
COOLING SYSTEM INSPECTION· · 6-3
COOLING SYSTEM TEST· · · · 6-4
RADIATOR· · · · · · · · · · · · · · · · · · 6-4
SERVICE INFORMATION
•Do not remove the radiator cap if the coolant temperature is over 100°C. Removing the cap while the engine is hot
and the coolant is under pressure may cause serious scalding. When the temperature is below, carefully remove the
cap with a cloth.
•Cooling system service should be done while the engine is cool.
•Radiator coolant is toxic. Keep it away from skin, eyes and clothes.
- If any coolant gets on your skin or clothes, rinse thoroughly with soap and water.
- If any coolant gets in your eyes, rinse them with water and consults a doctor immediately.
- If any coolant is swallowed, induce vomiting, gargle and consult a physician immediately.
- Especially pay attention to reserve the coolant. Keep out of reach of children.
● Do not remove the radiator cap except to refill or drain the cooling system after servicing the cooling system.
● Avoid spilling coolant on painted surfaces. If contaminated, wash in water immediately.
● After disassembling or servicing the cooling system, check for leaks with a radiator cap tester.
SPECIFICATIONS
RADIATOR CAP RELIEF PRESSURE
THERMOSTAT
TEMPERATURE
COOLANT CAPACITY
TORQUE VALUES :
WATER PUMP IMPELLER :
WATER PUMP COVER BOLT:
BEGIN TO OPEN
FULLY OPEN
VALVE LIFT
0.98~1.37㎏f·m
0.78~1.18㎏f·m
RADIATOR DISASSEMBLY· · 6-5
THERMOSTATIC SWITCH INSPECTION· · 6-6
RADIATOR ASSEMBLY· · · · · · 6-6
WATER PUMP· · · · · · · · · · · · · · · · 6-7
THERMOSENSOR· · · · · · · · · · 6-11
THERMOSTATIC· · · · · · · · · · · · 6-12
0.9 0.1kg/cm 2
80 2 C
90 C
3.5~4.5mm
Total system 1400 20cc
RADIATOR: 1000 20cc
RESERVE TANK : 400 20cc
6-1
6