Scaling; Warewashing Machine With Built-In Water Softening Device Ew10 (Upster H 500S)19; General; Adjustment Of Water Hardness - Meiko UPster H 500 Operating Instructions Manual

Operating Instructions UPster H 500 / H 500S
CAUTION!
CAUTION!
9735020
10.6 De-scaling
If the machine was operated with hard water, the boiler and wash tank could have lime
scale deposits. De-scaling of the tank interior, boiler housing, tank heating, boiler heating
and wash and final rinse system then becomes necessary.
For de-scaling the appliance use only products suitable for industrial dishwashers.
Please observe the product manufacturers' instructions.
After de-scaling the appliance:
 Completely flush the de-scaling agent out of the machine. 1 or 2 rinse cycles with
fresh water are necessary to achieve this.
Even small residues of de-scaling agents can be sufficient to destroy plastic parts and
sealing materials!
If the machine is heavily scaled, you should ask a service engineer from your local
MEIKO representative to de-scale the boiler.
11 Warewashing machine with built-in water softening
device EW10 (UPster H 500S)

11.1 General

If the red lamp lights up, the capacity of the water softener has been almost exhaust-
ed. About a further 10 program cycles are possible before the water softener is com-
pletely exhausted. It is therefore possible to delay the necessary regeneration until a
time when the machine is not in use.
It is important to note that if the machine continues to be used when the water sof-
tener is exhausted, capacity can be reduced and the machine may even become
unusable.

11.2 Adjustment of water hardness

The water softening device is pre-set to 30°Gh in the factory. When the service engineer
installs or commissions the appliance he should adjust this value depending on the actual
water hardness. Should there be any further changes in the water hardness, this parame-
ter must be adjusted accordingly as set out in the Short Programming Instructions.

11.3 Capacity of the built-in water softening device

2000
1800
1600
1400
1200
1000
800
600
400
200
0
5 10 15
Wasserhärte in °dH
Design and construction subject to change without prior notice!
Page
20 25 30
19 42
of