General Characteristics; Air Compressed Quality; Operation - Sames inocoat Inogun A Instruction Manual

3.5. General characteristics

Inogun A projector
Ambient temperature during operations
Maximum output voltage
Max. output current
High voltage unit capacity
Air pressure (electrode blowing)
Projector weight (cable and plug included)
Robotic version projector weight with a single support
Robotic version projector weight with double convergent support
Robotic version projector weight with double parallel support
Maximum operating altitude
Maximum relative humidity of 80% for temperatures up to 31°C, and
linear decrease to 50% relative humidity at 40°C.
Storage / Transport
Storage duration
Minimum/maximum storage temperature
Humidity
Min. pressure
Exposure to UV radiation
Exposure to ionizing radiation

3.6. Air compressed quality

Maximum dew point at 6 bar (87 psi)
Maximum particle-size of solid pollutants
Maximum oil concentration
Maximum concentration of solid pollutants
*: Values are given for a temperature of 20 °C (68 °F) at an atmospheric pressure of 1 013 mbar
Non-compliance with these characteristics may result in incorrect operation of
the"Inocontroller or Inobox control modules.
A 5 μm filter must be installed upstream of the compressed air supply of the Inocontroller or
Inobox control modules. This filter is sized according to the size of the installation.
Sames recommends using a filter of the type indicated in the section
In the event of damage to the equipment due to the use of polluted air, the warranty may not
be applied.

Operation

3.7.
The Inogun A projector is connected to an Inocontroller
This module provides the low voltage and high frequency power supply necessary for the operation of the high
voltage unit integrated in the Inogun A projector and allows the powder supply to the projector.
0° to 40°C
100 kV (0 kV, -10 kV)
110 μA (+ ou - 10 μA)
60 pF
< 1 bar
0.85 kg
1.19 kg
2.2 kg
2.16 kg
2000 m
maximum 80% non-condensing
Max. 2 years
-10°C + 45°C
95% non-condensing
750 mBar
Stored away from light
Not admitted
Class 4 i.e + 3°C (37°F)
Class 3 i.e 5 μm
Class 1 i.e 0,01 mg/m03 *
Class 3 i.e 5 mg/m03 *
(see DRT7134) or Inobox
23
DRT7133
D - 2023/01
(see § 8.13 page 75).
(see DRT7145) control module.
Member of Exel group