Checking The Brake Operation; Checking The Brake Fluid Level - Yamaha TMAX XP500F 2015 Service Manual

5. Check:
• V-belt case air filter elements
Damage → Replace.
ECA13440
NOTICE
Since the V-belt case air filter element is a
dry type, do not let grease or water contact it.
6. Install:
• V-belt case air filter element (right)
• V-belt case air filter case
• V-belt case air filter case cover
V-belt case air filter case screw
7 Nm (0.7 m·kgf, 5.1 ft·lbf)
V-belt case air filter case cover
screw
7 Nm (0.7 m·kgf, 5.1 ft·lbf)
7. Install:
• V-belt case air filter element (left)
V-belt case air filter element bolt
(left side)
7 Nm (0.7 m·kgf, 5.1 ft·lbf)
8. Install:
• Footboards
Refer to "GENERAL CHASSIS (2)" on page
4-8.
• Center cover
Refer to "GENERAL CHASSIS (2)" on page
4-8.
PERIODIC MAINTENANCE
EAS30801

CHECKING THE BRAKE OPERATION

1. Check:
• Brake operation
Brake not working properly → Check the
brake system.
Refer to "FRONT BRAKE" on page 4-39 and
"REAR BRAKE" on page 4-53.
TIP
Drive on the road, operate the front and rear
brakes separately and check to see if the brakes
are operating properly.
EAS30632

CHECKING THE BRAKE FLUID LEVEL

1. Stand the vehicle on a level surface.
TIP
• Place the vehicle on the centerstand.
• Make sure the vehicle is upright.
2. Check:
• Brake fluid level
Below the minimum level mark "a"→ Add the
specified brake fluid to the proper level.
Specified brake fluid
DOT 4
A. Front brake
B. Rear brake
3-13