Checking The Wheel Bearings - Yamaha TMAX XP500F 2015 Service Manual

Tire air pressure (measured on
cold tires)
Loading condition
0–90 kg (0–198 lb)
Front
225 kPa (2.25 kgf/cm², 33 psi,
2.25 bar)
Rear
250 kPa (2.50 kgf/cm², 36 psi,
2.50 bar)
Loading condition
90–195 kg (198–430 lb)
Front
225 kPa (2.25 kgf/cm², 33 psi,
2.25 bar)
Rear
280 kPa (2.80 kgf/cm², 41 psi,
2.80 bar)
Maximum load
195 kg (430 lb)
* Total weight of rider, passenger, cargo
and accessories
EWA13190
WARNING
It is dangerous to ride with a worn-out tire.
When the tire tread reaches the wear limit, re-
place the tire immediately.
2. Check:
• Tire surfaces
Damage/wear → Replace the tire.
1. Tire tread depth
2. Side wall
3. Wear indicator
Wear limit (front)
1.0 mm (0.04 in)
Wear limit (rear)
1.0 mm (0.04 in)
PERIODIC MAINTENANCE
EWA14090
WARNING
After extensive tests, the tires listed below
have been approved by Yamaha Motor Co.,
Ltd. for this model. The front and rear tires
should always be by the same manufacturer
and of the same design. No guarantee con-
cerning handling characteristics can be giv-
en if a tire combination other than one
approved by Yamaha is used on this vehicle.
Front tire
Size
120/70R15 M/C 56H
Manufacturer/model
DUNLOP/GPR-100F
Rear tire
Size
160/60R15 M/C 67H
Manufacturer/model
DUNLOP/GPR-100
EWA13210
WARNING
New tires have a relatively low grip on the
road surface until they have been slightly
worn. Therefore, approximately 100 km
should be traveled at normal speed before
any high-speed riding is done.
TIP
For tires with a direction of rotation mark "1":
• Install the tire with the mark pointing in the di-
rection of wheel rotation.
• Align the mark "2" with the valve installation
point.
EAS30641

CHECKING THE WHEEL BEARINGS

The following procedure applies to all of the
wheel bearings.
3-19