Audi A4 2015 Repair Manual page 103

4-Cylinder Direct Injection 2.0L 4V TFSI Engine (EA 888 Generation III) - Edition 11.2019
– Equipped on some models: loosen the hose clamps -arrows-
and remove the coolant hoses from the ATF cooler and let the
coolant run out.
• Secure all hose connections with hose clamps that match the
ones used in series production. Refer to the Parts Catalog.
– Tighten the drain plug and close the coolant hoses again.
Coolant Specification
Refer to ⇒ Servicing – 4-Cylinder 2.0L 4V TFSI Engine (EA 888
Generation III); Rep. Gr. 19 ; Coolant System/Coolant; Coolant,
Draining and Filling .
Coolant Mixture Ratio
CAUTION
There is a risk of corrosion damage from an unsuitable mixture
of water and coolant additive.
– Only use distilled water for optimal corrosion protection
• Coolant (40%) and distilled water (60%) for freeze protection
down to -25 ºC (-13 °F)
• Coolant (50%) and distilled water (50%) for freeze protection
down to -36 ºC (-32.8 °F)
• Coolant. Refer to the Parts Catalog.
Coolant, Filling
• Used coolant cannot be used again.
– Fill the coolant reservoir from the -VAS6096- with 10 liters of
coolant with the correct mixture ratio. Refer to
the mixture ratio.
– To make the filling procedure easier, position the coolant res‐
ervoir as high up as possible, for example on a workshop cart
or the engine and gearbox jack.
– Install the -VAG1274/8- on the coolant expansion tank -1-.
– Attach the -VAS6096- on the -VAG1274/8- .
– Place the drain hose -2- in a small container -3-.
TIP:
A small amount of coolant which should be collected is drawn off
with the discharged air.
– Close the valves -A and B- by turning lever at a right angle to
the flow direction.
– Connect the hose -4- to compressed air.
• Pressure: 7 to 10 bar (101.52 psi to 145.03 psi) positive pres‐
sure.
– Open the coolant circuit valves and select
circuit bleeding
Diagnostic Tester .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Audi A4 2015 ➤ , Audi A4 China 2016 ➤ , Audi A5 2016 ➤
01 - coolant
in
Guided Functions
⇒ page 97 for
using the Vehicle
1. Coolant System/Coolant
97