Quadratec QuadraTop Adventure Top S Manual page 10

FIG 51
Step 10: Installing
Deck (Continued): Thread
tensioner through the flap/tube sewn into the
t h e
top deck and attach
the spring assembly that
of the top deck (FIG
this procedure on the other
vehicle. Go to the front of the vehicle and fold
the front header down to the
do not latch. Loosely
tighten
straps, starting on one side and alternating
to the other so the top deck
Make sure the tube/strap is
of the Door Surround and the
located over the rear bow
loosely tightening,
When the
attached to the spring will fit under
installed screw on the
door surround (FIGS
53 & 54). SEE Note to Right!
FIG 55
FIG 57
Step 11: Installing the Side and Rear Windows
To ensure the top is centered on the vehicle you
will be installing the two quarter windows and the
rear window to the top deck and then to each
other before securing it to the vehicle body.
Pro-Install TIP: To make this as easy as
possible, the front windshield header should be
released(not clamped down) and keep the rear
corner straps installed in step 10 loosened.
This will allow you to line up all window zippers
and attachments. The rear corner straps and
header will need to be re-tightened/clamped
before using the top.
FIG 52
the Top
FIG 53
the end of the
t e n s i o n e r
to
is hanging out
51).
Repeat
side of the
windshield but
rear
the
is centered.
on the outside
strap is
leg (FIG 52).
NOTE: Do not fully tighten these straps until
cable that is
advised to do so in step 11 when the front
the pre-
header
windshield. If these straps are fully tightened
before
you will damage the top!
FIG 56
Locate the drivers rear quarter window. Line
up and slide the rear quarter window into the
"C" Channel as shown in FIG's 55 & 56 .
Repeat this on the passenger side of the
vehicle.
Locate the rear window and line up and slide
the rear window into the "P" Channel located
at the top of the rear portion of the top deck
and slide it across (FIGs 57 & 58).
10
FIG 54
and latched
is closed on
you fold down the front
FIG 58
the
header