Maximum Power Consumption - Minimum Recommended Conductor Cross Sectional Area; Battery Maintenance - Zepro ZHD 2500-130 Installation Instructions Manual

Specifications
16.2 Maximum power consumption -
Minimum recommended conductor cross sectional area
Hydraulic unit 7050
Pump - Motor unit
Magnet (hydraulic unit)
Magnet (electric safety valve)
Solenoid
Minimum recommended cross sectional area
(applies to copper cables, positive and negative cable)
Control cable
Supply cable, L < 8 m
Supply cable, L = 8 - 15 m
Supply cable, L > 15 m
Battery
Min. capacity, I
Min. voltage during operation, U
(during lift)
I
min
-
+
I
min
-
+
16.3

Battery maintenance

When storing for longer than 1 week, you are recommended to disconnect the lift from the battery via the
main switch or by releasing the lift's main fuse, in order to reduce the risk of the battery discharging. The
length of time the vehicle can be stored without the battery's charge level becoming too low depends on the
condition of the battery, the charge level before storage and how much power the vehicle's other components
take from the battery. After a period of storage, the battery must always be charged fully before operating the
lift.
When installing the lift and when carrying out service and repair work, when the lift is operated repeatedly
without the vehicle being started and used, the battery charger must be used between operations to maintain
the battery's charge level.
NOTE.
The battery charger must not be connected when operating the lift. Risk of damage.
64
ZHD 2500 (200 bar)
(available for lift)
min
min
U
L
Image 70. Maximum power consumption - Minimum rec-
ommended conductor cross sectional area
12 volt 24 volt
245 A 135 A
4.2 A 2.1 A
1.5 A 0.75 A
1.8 A 0.9 A
1.5 mm 1.5 mm
2 2
35 mm 35 mm
2 2
50 mm 35 mm
2 2
- 50 mm
2
180 Ah 170 Ah
9 Volt 18 Volt
min
L
ZHD 2500-130/150
NOTE.
Ensure that the lift has
access to the minimum
recommended power
capacity (I ) Some ve-
min .
hicles have restrictions
regarding the amount of
power the lift can access
from the existing battery.
U
min
www.zepro.com