Safety Advice; Safety Rules And Regulations - SaMASZ KDD 860 Operator's Manual

4. SAFETY ADVICE

4.1. Safety rules and regulations

Front axis of the tractor should be weighted to keep the balance. If need be, use front wheel
weights.
Any operation with hydraulic lift lever should be done from operator's seat; DO NOT move
the lever from outside of a tractor.
In case of tractors equipped with EHR, operating with hydraulic lift is done by the buttons
mounted outside the tractor's cabin. When operating be extremely careful.
When switching from working to transport position unmount the whole or at least one end (from
tractor's PTO) of PTO shaft.
Operation without safety guards as well as with damaged or raised guards is not allowed
(danger of stones, etc. being thrown out).
Start mowing only when tractor's PTO reaches its normal 1000 rpm.
DO NOT exceed 1050 PTO rpm,
Nobody is allowed to remain within danger area of at least 50 m. Particular caution is necessary
when operating near roads and in stoney areas,
Any maintenance and adjustment work should only be done after the drive has been
disconnected and when cutting discs have come to complete standstill,
Always check mower before starting work, in particular for damaged, missing and/or worn
knives and knife holders. Damaged or worn parts must be replaced.
When driving on public roads always comply with local traffic regulations, especially
concerning warning lights.
CAUTION:
All service and repair operations must be done only after tractor's
engine has been stopped, all rotating parts have come to complete
standstill and the cutterbar is on the ground.
CAUTION:
Be certain that children and animals are at a safe distance away from
the machine. Never allow anyone to ride on a machine or tractor.
When the mower is lifted for repair on 3-point linkage, it should be secured against
falling by mechanical support or by chain.
The bolts and other fasteners have to be periodically checked and, if necessary, tightened or
replaced. DO NOT work with damaged or worn fasteners.
Never lift the mower on tractor linkage when the drive is on and the cutting discs are rotating.
During operation of the mower the Regulation of the Farm Ministry and Food Economy
(Rozporządzenie Ministra Rolnictwa i Gospodarki
with safety and hygiene during the operation of tractors, machinery, tools andequipment used
for farming (Dz. U. Nr 12/98 poz. 51), should be observed,
When operating the mower, the tractor should always be equipped with cabin.
Mower should not be operated when the tractor-mower set is not balanced.
Never start the mower when it is lifted.
Never start the mower, when people or animals are near the machine.
Never lift safety guard before rotating parts have come to complete standstill. Tractor's engine
must be stopped.
Always comply with safety decals describing hazards and warning signs placed on the machine.
Before you start the tractor make sure that every other drives are turned off and the levers
steering hydraulics are in neutral position.
Operator's manual
- 9 -
Double-sided disc mowers
with central suspension
ywnościowej) from 12-01-1998 dealing