Section 10 - Preventive Maintenance; Regular Preventative Maintenance - Performed By Owner; Daily; Weekly: (Plus Daily Preventive Maintenance) - Precor TRM10/GEN06 Service Manual

Section 10 - Preventive Maintenance

Cleanliness of the equipment and its operating environment will keep
maintenance problems and service calls to a minimum. Precor recommends
the following preventative maintenance schedule.
In This Section

Regular Preventative Maintenance - performed by owner

On-Site Preventative Maintenance - performed by Service Technician
Preventative Maintenance Checklist (Facility personnel)
Preventative Maintenance Checklist (Service Technician)
Regular Preventative Maintenance - performed by owner
The following steps are recommended to be done on a regular basis as
indicated by owner/facility personnel.

Daily

1 Turn off power switch/circuit breaker and unplug the power cord from
the wall outlet.
2 Visually inspect the running deck and belt, make sure that neither the
bed or belt is worn or damaged.
The top side of the belt is a friction/running surface and should NOT be
used to indicate belt wear. Belt wear is all about the under-surface that
touches the deck. Any belt thought to be worn to the point of needing
replacement must be verified by the current draw of the machine.
3 Wipe down the running bed and belt, using a dry or lightly moistened
cloth to clean the top surface of the running belt.
4 Clean all other surfaces of the unit with a diluted solution of simple
green and water (30 parts water to 1 part simple green). Be sure to
dampen the cloth with the solution and then wipe the machine down.
Do not spray liquid directly onto the machine and then wipe.
5 Inspect the power cord, make sure it is not damaged or positioned at
risk of being damaged by the lift mechanism. The power cord is
detachable, make sure there is a cord clamp installed.

Weekly: (Plus Daily Preventive Maintenance)

1 Elevate the treadmill to maximum elevation, then turn off the power
switch/circuit breaker and unplug the power cord from the wall outlet.
© Precor Incorporated, Unauthorized Reproduction and Distribution Prohibited by Law
127
130
133
134
Page 127