Recommended Work - Husqvarna TC 125 2017 Owner's Manual

9 SERVICE SCHEDULE
Grease all moving parts (e.g., hand lever, chain, ...) and check for smooth operation.
Check/correct the fluid level of the hydraulic clutch. (
Check the front brake fluid level. (
Check the free travel of the hand brake lever. (
Check the play of the steering head bearing. (
Change the spark plug and spark plug connector.
Check all hoses (e.g. fuel, cooling, bleeder, drainage, etc.) and sleeves for cracking, leaks, and incorrect rout-
ing.
Check the antifreeze and coolant level. (
Check the cables for damage and routing without sharp bends.
Check that the throttle cables are undamaged, routed without sharp bends, and set correctly.
Clean the air filter and air filter box.
Change glass fiber yarn filling in the main silencer.
Check the screws and nuts for tightness.
Check idle.
Final check: Check the vehicle for safe operation and take a test ride.
Make the service entry in the Husqvarna Motorcycles Dealer.net and in the Service and Warranty Booklet.
○
One-time interval
●
Periodic interval
9.2.3

Recommended work

Change the front brake fluid.
Change the rear brake fluid.
Change the hydraulic clutch fluid.
Grease the steering head bearing.
Service the fork.
Service the shock absorber.
Check the starter drive.
Check the inlet membrane.
Check/adjust the carburetor components.
Perform minor engine service. (Check the exhaust control for functioning and smooth operation. Check
the clutch.)
Perform major engine service including removing and installing the engine. Change the piston and
check the cylinder. Change the connecting rod, conrod bearing, and crank pin. Check the transmis-
sion and shift mechanism. Change all engine bearings.)
○
One-time interval
●
Periodic interval
p. 70)
p. 73)
p. 72)
p. 48)
p. 91)
( p. 57)
( p. 59)
Every 80 operating hours/every 40 operating hours when used for motorsports
( p. 70)
( p. 49)
Every 40 operating hours/after every race
Every 20 operating hours
Once after 1 operating hour
Every 40 operating hours/after every race
Every 20 operating hours
Once after 10 operating hours
32
● ●
● ●
● ●
● ●
○ ● ●
● ●
○ ● ●
○ ● ●
● ●
○ ● ●
● ●
● ●
○ ● ●
○ ● ●
○ ● ●
○ ● ●
Annually
●
●
●
●
○ ● ●
● ●
● ●
● ● ●
● ●
● ●
●