Every 400 Hours; Changing Transmission Fluid; Changing Front And Rear Axle Case Oil; Every 500 Hours - Hisun HS 500 Owner's Manual

EVERY 400 HOURS

■ Changing Transmission Fluid

CAUTION
To avoid personal injury:

Park the vehicle on a flat surface, raise the
cargo bed, mount the safety support.

Allow engine to cool down sufficiently, oil
can be hot and can burn.
1. Park the vehicle on a flat surface, raise the
cargo bed, mount the safety support.
2. To drain the used oil, remove the drain plug at
the bottom of the transmission case and drain
the oil completely into the oil pan.
3. After draining, reinstall the drain plug.
4. After running the engine for a few minutes,
stop the engine and check the oil level again;
add oil to prescribed level.
① Drain plug
IMPORTANT:

Do not operate the vehicle immediately after
changing the transmission fluid.

Run the engine at medium speed for a few
minutes to prevent
transmission.

■ Changing Front and Rear Axle Case Oil

1. Park the vehicle on a firm, flat and level
surface.
PERIODIC SERVICE
damage to the
11-15
2. To drain the used oil, remove the drain the oil
completely into the oil pan.
3. Fill with the new oil up to the upper notch on
the dipstick.
(See "LUBRICANTS, FUEL AND COOLANT"
in "MAINTENANCE" section.)
4. After filling, reinstall the filling plug.
Oil capacity for
front axle
case
Oil capacity for
rear axle case
①
Front axle case drain plug
②
Rear axle case drain plug

EVERY 500 HOURS

■ Replacing Fuel Filter

Consult your local dealer for this service.

EVERY 600 HOURS

0.6L（0.6U.S.gals.）
?