Checking Intake Air Line; Every 300 Hours; Checking The Tire - Hisun HS 500 Owner's Manual

hardened or cracked. Replace hoses and
hose clamps every 2 years or earlier, if
checked and found that hoses are swollen,
hardened or cracked.
① Radiator hose ② Clamp bands
◆ Precaution at Overheating
Take the following actions in the event the coolant
temperature is close to or more than the boiling
point, which is called "Overheating".
1. Stop the vehicle operation in a safe place and
keep the engine unloaded idling.
Don't stop the engine suddenly, but stop it
2.
after about 5 minutes of unloaded idling.
3. Keep yourself well away from the vehicle for at
least 10 minutes or while the steam is blowing
out.
4. Check to see if there is no danger such as
burning, get rid of the causes of overheating
the
by following
section of the manual, and then start the
PERIODIC SERVICE
"TROUBLESHOOTING"
engine again.

■ Checking Intake Air Line

1. Check to see if the hoses and hose clamps
are tight and not damaged.
2. If hoses and clamps are found to be worn or
damaged, replace or repair them at once.
① Hose

EVERY 300 HOURS

■ Checking the Tires
1. Check to see if the tires are damaged.
2. If the tires are cracked, bulged, or cut, or they
are worn out, replace or repair them at once.
◆ Tire Tread Depth
Always replace the tires when the tread depth is
worn to minimum allowable.
① 3mm(0.12in)
11-14
② Hose joint