Table Of Contents - Invacare Storm4 Max Service Manual

® 4
Invacare - STORM
Contents
Chapter
1 Introduction
1.1 General information ..................................................................................................................8
1.2 Notes on transport ....................................................................................................................8
1.3 Definition and representation of information and safety information in this manual........9
1.4 Hazard symbols and symbols used ......................................................................................10
1.5 Images in this manual .............................................................................................................11
2 Safety and fitting instructions
2.1 Before any inspection or repair work....................................................................................12
2.2 Personal safety equipment.....................................................................................................12
2.3 General safety information and information about fitting / removal..................................12
3 Tightening torques
4 Layout of components and componentry
4.1 Overview...................................................................................................................................16
4.2 Electronics modules ...............................................................................................................17
4.2.1 ACS 2 PMA90L electronics module .............................................................................18
4.2.2 ACT actuator module....................................................................................................18
4.2.2.1
4.2.2.2
4.2.3 Lighting PCB.................................................................................................................19
4.3 Joystick boxes .........................................................................................................................20
5 Service plan (1x annually)
6 Operational faults
6.1 Drive fault diagnosis ...............................................................................................................26
6.2 REM remotes: Error codes and diagnostic codes ...............................................................31
6.3 Diagnosis of charging device faults......................................................................................32
7 Repair work
7.1 Covers.......................................................................................................................................33
7.1.1 Opening the rear cover panel .......................................................................................33
7.1.2 Opening the centre panel .............................................................................................34
7.1.3 Opening the front panel ................................................................................................36
7.1.4 Opening the rear light cover .........................................................................................37
7.1.5 Replacing the splash guard ..........................................................................................38
MAX
ACT 2 actuator module............................................................................................18
ACT 4 actuator module............................................................................................18
SERVICE MANUAL
Page
8
12
15
16
22
25
33
5