Chrysler 2004 Concorde Service Manual page 1657

LH
Description
OIL SEAL RETAINER - REMOVAL,
CRANKSHAFT REAR . . . . . . . . . . . . . . . . . . . 9-50
OIL SEAL(S) - INSTALLATION,
CAMSHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . 9-26
OIL SEAL(S) - REMOVAL, CAMSHAFT
ON-BOARD DIAGNOSTIC SYSTEM -
DIAGNOSIS AND TESTING . . . . . . . . . . . . . . 8F-18
OPEN-CIRCUIT VOLTAGE TEST -
STANDARD PROCEDURE . . . . . . . . . . . . . . . 8F-10
OPENING DIMENSION -
SPECIFICATIONS, BODY . . . . . . . . . . . . . . 23-118
OPENING REINFORCEMENT -
INSTALLATION, GRILLE . . . . . . . . . . . . . . . . 23-37
OPENING REINFORCEMENT - REMOVAL,
GRILLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-36
OPENING WEATHERSTRIP -
INSTALLATION, DOOR . . . . . . . . . . . . . . . . 23-110
OPENING WEATHERSTRIP -
INSTALLATION, TRUNK . . . . . . . . . . . . . . . 23-114
OPENING WEATHERSTRIP - REMOVAL,
DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-110
OPENING WEATHERSTRIP - REMOVAL,
TRUNK . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-114
ORVR - DESCRIPTION . . . . . . . . . . . . . . . . . 25-14
ORVR - OPERATION . . . . . . . . . . . . . . . . . . 25-14
OUTER TIE ROD - INSTALLATION . . . . . . . . 19-51
OUTER TIE ROD - REMOVAL . . . . . . . . . . . 19-51
OUTER TIE ROD SOCKET END PLAY -
DIAGNOSIS AND TESTING . . . . . . . . . . . . . 19-50
OUTLET - DESCRIPTION, CIGAR
LIGHTER/POWER . . . . . . . . . . . . . . . . . . 8W-97-2
OUTLET - INSTALLATION, CIGAR
LIGHTER/POWER . . . . . . . . . . . . . . . . . . 8W-97-3
OUTLET - OPERATION, CIGAR
LIGHTER/POWER . . . . . . . . . . . . . . . . . . 8W-97-2
OUTLET - REMOVAL, CIGAR LIGHTER/
POWER . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-97-2
OUTLET CONNECTOR - 2.7L -
INSTALLATION, COOLANT . . . . . . . . . . . . . . . 7-20
OUTLET CONNECTOR - 2.7L - REMOVAL,
COOLANT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-20
OUTLET CUSTOMER PREFERENCE -
STANDARD PROCEDURE, CIGAR
LIGHTER/POWER . . . . . . . . . . . . . . . . . . 8W-97-2
OUTPUT - DESCRIPTION, SPEED
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-144
OUTPUT - INSTALLATION, SPEED
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-145
OUTPUT - OPERATION, 5 VOLT SUPPLY -
PCM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-12
OUTPUT - OPERATION, SPEED SENSOR . . 21-145
OUTPUT - REMOVAL, SPEED SENSOR
OVERHEAD CONSOLE - DESCRIPTION
OVERHEAD CONSOLE - DIAGNOSIS AND
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-1
OVERHEAD CONSOLE - OPERATION
OVERHEAD CONSOLE - REMOVAL . . . . . . . . 8M-7
PAINT CODE - DESCRIPTION . . . . . . . . . . . 23-77
PAINT SURFACE TOUCH-UP -
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . 23-77
PAN - INSTALLATION, OIL . . . . . . . . . . . . . . . 9-65
PAN - REMOVAL, OIL . . . . . . . . . . . . . . . . . . 9-64
PANEL - INSTALLATION, GLASS
PANEL - INSTALLATION, REAR SHELF
TRIM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-72
PANEL - INSTALLATION, SAIL . . . . . . . . . . . 23-32
PANEL - INSTALLATION, TRIM
. . . . . 23-24,23-31
PANEL - REMOVAL, GLASS . . . . . . . . . . . . 23-106
PANEL - REMOVAL, REAR SHELF TRIM
PANEL - REMOVAL, SAIL
. . . . . . . . . . . . . . 23-32
PANEL - REMOVAL, TRIM . . . . . . . . . 23-23,23-31
PANEL ASSEMBLY - INSTALLATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-55
PANEL ASSEMBLY - REMOVAL,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-47
PANEL CENTER BEZEL - INSTALLATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
PANEL CENTER BEZEL - REMOVAL,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
PANEL DEMISTER DUCTS -
DESCRIPTION, INSTRUMENT . . . . . . . . . . . 24-26
PANEL DEMISTER DUCTS - OPERATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 24-26
PANEL END CAP - INSTALLATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
PANEL END CAP - REMOVAL,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
Group-Page Description
PANEL REPAIR - STANDARD
PROCEDURE, PLASTIC BODY . . . . . . . . . . . . 23-3
PANEL SILENCER - INSTALLATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
. . . . . 9-26 PANEL SILENCER - REMOVAL,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-56
PANEL TIMING - ADJUSTMENT,
SUNROOF GLASS . . . . . . . . . . . . . . . . . . . 23-106
PANEL TOP COVER - INSTALLATION,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-57
PANEL TOP COVER - REMOVAL,
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 23-57
PARKING BRAKE - ADJUSTMENT
PARKING BRAKE - DESCRIPTION
PARKING BRAKE - OPERATION . . . . . . . . . . . 5-53
PARKING BRAKE CABLE TENSIONER -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 5-54
PARKING BRAKE CABLE TENSIONER -
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54
PARKING BRAKE LEVER AND CABLE -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 5-59
PARKING BRAKE LEVER AND CABLE -
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-57
PARKING BRAKE SHOES -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 5-60
PARKING BRAKE SHOES - REMOVAL . . . . . . 5-60
PARK/TURN SIGNAL LAMP -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . 8L-36
PARK/TURN SIGNAL LAMP - REMOVAL
PASSENGER AIRBAG - DESCRIPTION
PASSENGER AIRBAG - INSTALLATION
PASSENGER AIRBAG - OPERATION
PASSENGER AIRBAG - REMOVAL . . . . . . . . 8O-18
PASSENGER HEATED SEAT SWITCH -
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . 8G-13
PASSENGER HEATED SEAT SWITCH -
DIAGNOSIS AND TESTING . . . . . . . . . . . . . 8G-14
PASSENGER HEATED SEAT SWITCH -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . 8G-14
PASSENGER HEATED SEAT SWITCH -
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . 8G-13
PASSENGER HEATED SEAT SWITCH -
REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . 8G-14
PASSENGER POWER SEAT SWITCH -
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . 8N-17
PASSENGER POWER SEAT SWITCH -
DIAGNOSIS AND TESTING . . . . . . . . . . . . . 8N-17
PASSENGER POWER SEAT SWITCH -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . 8N-18
PASSENGER POWER SEAT SWITCH -
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . 8N-17
. . . 21-145 PASSENGER POWER SEAT SWITCH -
. . . . 8M-1 REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-18
PASSENGER VEHICLES - INSTALLATION,
OCCUPANT RESTRAINT CONTROLLER
. . . . . . 8M-1 - 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-16
PASSENGER VEHICLES - INSTALLATION,
OCCUPANT RESTRAINT CONTROLLER
- 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-17
PASSENGER VEHICLES - INSTALLATION,
STORAGE BIN - 5 . . . . . . . . . . . . . . . . . . . . 23-58
PASSENGER VEHICLES - INSTALLATION,
. . . . . . . . 23-106 STORAGE BIN - 6 . . . . . . . . . . . . . . . . . . . . 23-58
PASSENGER VEHICLES - REMOVAL,
OCCUPANT RESTRAINT CONTROLLER
- 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-15
PASSENGER VEHICLES - REMOVAL,
OCCUPANT RESTRAINT CONTROLLER
- 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8O-16
. . . 23-71
PASSENGER VEHICLES - REMOVAL,
STORAGE BIN - 5 . . . . . . . . . . . . . . . . . . . . 23-58
PASSENGER VEHICLES - REMOVAL,
STORAGE BIN - 6 . . . . . . . . . . . . . . . . . . . . 23-58
PATTERNS - DIAGNOSIS AND TESTING,
TIRE WEAR . . . . . . . . . . . . . . . . . . . . . . . . . 22-16
PCM GROUND - OPERATION
PCM INPUT - OPERATION, DATA BUS
COMMUNICATION RECEIVE . . . . . . . . . . . . . 8E-11
PCM INPUT - OPERATION, IGNITION
SENSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-11
PCM INPUT - OPERATION, SENSOR
RETURN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-11
PCM OUTPUT - OPERATION, 5 VOLT
SUPPLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-12
PCM/SKIM PROGRAMMING - STANDARD
PROCEDURE . . . . . . . . . . . . . . . . . . . . . . . . . 8E-1
PCV HOSE - DESCRIPTION
PCV HOSE - INSTALLATION
Group-Page Description
PCV HOSE - REMOVAL
PCV SYSTEM - DIAGNOSIS AND
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . 25-17
PCV VALVE - DESCRIPTION
PCV VALVE - OPERATION
PEDAL - DESCRIPTION
PEDAL - INSTALLATION
PEDAL - INSTALLATION, ACCELERATOR . . . 14-22
PEDAL - OPERATION . . . . . . . . . . . . . . . . . . . 5-41
PEDAL - REMOVAL
PEDAL - REMOVAL, ACCELERATOR
PERFORMANCE - DIAGNOSIS AND
. . . . . . . . . 5-53 TESTING, ENGINE DIAGNOSIS . . . . . . . . . . . . 9-8
. . . . . . . . . 5-53 PERFORMANCE TEST - DIAGNOSIS AND
TESTING, A/C . . . . . . . . . . . . . . . . . . . . . . . . 24-1
PERFORMANCE TEST - DIAGNOSIS AND
TESTING, HEATER . . . . . . . . . . . . . . . . . . . . . 24-2
PIN BUSHINGS - ASSEMBLY, CALIPER
GUIDE . . . . . . . . . . . . . . . . . . . . . . . . . . 5-25,5-32
PIN BUSHINGS - DISASSEMBLY,
CALIPER GUIDE . . . . . . . . . . . . . . . . . . 5-22,5-29
PINION FACTOR PROCEDURE -
STANDARD PROCEDURE . . . . . . . . . . . . . . . 8E-12
PISTON & CONNECTING ROD -
DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . 9-51
PISTON & CONNECTING ROD -
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 9-52
PISTON & CONNECTING ROD -
. . . 8L-36 REMOVAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-51
. . . . 8O-17 PISTON AND SEAL - ASSEMBLY,
. . . . 8O-19 CALIPER . . . . . . . . . . . . . . . . . . . . . . . . . . 5-26,5-33
. . . . . . 8O-17 PISTON AND SEAL - DISASSEMBLY,
CALIPER . . . . . . . . . . . . . . . . . . . . . . . . 5-22,5-30
PISTON RING FITTING - STANDARD
PROCEDURE . . . . . . . . . . . . . . . . . . . . . . . . . 9-54
PISTON RINGS - INSTALLATION . . . . . . . . . . 9-55
PISTON RINGS - REMOVAL
PISTONS - STANDARD PROCEDURE,
FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-51
PLANETARY GEARTRAIN - DESCRIPTION . 21-124
PLANETARY GEARTRAIN - OPERATION
PLASTIC BODY PANEL REPAIR -
STANDARD PROCEDURE . . . . . . . . . . . . . . . . 23-3
PLASTIGAGE - STANDARD PROCEDURE,
MEASURING BEARING CLEARANCE
USING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-13
PLATE - DESCRIPTION, MANUFACTURER . Intro.-11
PLATE - INSTALLATION, FLEX . . . . . . . . . . . . 9-51
PLATE - REMOVAL, FLEX
PLATE LAMP - INSTALLATION, LICENSE
PLATE LAMP - REMOVAL, LICENSE
PLATE LAMP UNIT - INSTALLATION,
LICENSE . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-32
PLATE LAMP UNIT - REMOVAL, LICENSE . . 8L-31
PLATES - DESCRIPTION, BODY CODE
PLATINUM PLUGS - DESCRIPTION
PLAY - DIAGNOSIS AND TESTING,
OUTER TIE ROD SOCKET END . . . . . . . . . . 19-50
PLAY - STANDARD PROCEDURE,
CRANKSHAFT END . . . . . . . . . . . . . . . . . . . . 9-43
PLAY - STANDARD PROCEDURE,
MEASURING CAMSHAFT END . . . . . . . . . . . . 9-26
PLUG - INSTALLATION, SPARK
PLUG - REMOVAL, SPARK . . . . . . . . . . . . . . . 8I-8
PLUG TUBE - INSTALLATION, SPARK . . . . . . 9-37
PLUG TUBE - REMOVAL, SPARK
PLUGS - DESCRIPTION, PLATINUM . . . . . . . . 8I-8
PLUGS - STANDARD PROCEDURE,
ENGINE CORE AND OIL GALLERY . . . . . . . . 9-12
PLUGS, SPECIFICATIONS - SPARK
PLUMBING - WARNING . . . . . . . . . . . . . . . . 24-28
PLUS - DESCRIPTION, ABS
PLUS - OPERATION, ABS
POINTS - DESCRIPTION, LUBRICATION
POLISHING - DESCRIPTION, FINESSE
. . . . . . . . . . . 8E-12 SANDING/BUFFING . . . . . . . . . . . . . . . . . . . 23-77
PORT VALVE CORE - INSTALLATION,
SERVICE . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-44
PORT VALVE CORE - REMOVAL,
SERVICE . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-43
POSITION LAMP - EXPORT -
DESCRIPTION, FRONT . . . . . . . . . . . . . . . . . 8L-15
POSITION LAMP - EXPORT - DIAGNOSIS
AND TESTING, FRONT . . . . . . . . . . . . . . . . . 8L-15
POSITION LAMP - EXPORT -
INSTALLATION, FRONT . . . . . . . . . . . . . . . . 8L-15
. . . . . . . . . . . . . 25-15
POSITION LAMP - EXPORT -
OPERATION, FRONT . . . . . . . . . . . . . . . . . . 8L-15
. . . . . . . . . . . . 25-16
INDEX 17
Group-Page
. . . . . . . . . . . . . . . . 25-15
. . . . . . . . . . . . 25-16
. . . . . . . . . . . . . . 25-17
. . . . . . . . . . . . . . . . . 5-41
. . . . . . . . . . . . . . . . 5-41
. . . . . . . . . . . . . . . . . . . . 5-41
. . . . . . 14-21
. . . . . . . . . . . . . 9-55
. . 21-124
. . . . . . . . . . . . . . . 9-51
. . 8L-31
. . . . . . 8L-31
. . . Intro.-1
. . . . . . . . 8I-8
. . . . . . . . . . . 8I-8
. . . . . . . . . 9-37
. . . . . . . . 8I-2
. . . . . . . . . . . . . 5-61
. . . . . . . . . . . . . . . 5-63
. . . . . 0-6