Replacing The Headlight Bulbs; Checking And Charging The Battery; Checking The Fuses - Yamaha 2012 TMAX XP500A Service Manual

4. Adjust:
• Throttle grip free play
TIP
Prior to adjusting the throttle grip free play,
throttle body synchronization should be
adjusted properly.
▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼
a. Slide back the rubber cover "1".
b. Loosen the locknut "2".
c. Turn the adjusting nut "3" in direction "a" or
"b" until the specified throttle grip free play
is obtained.
Direction "a"
Throttle grip free play is increased.
Direction "b"
Throttle grip free play is decreased.
d. Tighten the locknut.
Locknut
3.8 Nm (0.38 m·kgf, 2.8 ft·lbf)
e. Slide the rubber cover to its original posi-
tion.
TIP
Make sure that the adjusting nut is covered
completely by the rubber cover.
▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲
PERIODIC MAINTENANCE
EAS21760

CHECKING AND CHARGING THE BATTERY

Refer to "CHECKING AND CHARGING THE
BATTERY" on page 8-127.
EAS21770

CHECKING THE FUSES

Refer to "CHECKING THE FUSES" on page 8-
127.
EAS21790

REPLACING THE HEADLIGHT BULBS

The following procedure applies to both of the
headlight bulbs.
1. Remove:
• Front cover
Refer to "GENERAL CHASSIS" on page
4-1.
2. Disconnect:
• Headlight coupler "1"
3. Remove:
• Headlight bulb "1"
EWA13320
WARNING
Since the headlight bulb gets extremely
hot, keep flammable products and your
hands away from the bulb until it has
cooled down.
4. Install:
• Headlight bulb
3-33
New