Error Messages - Ravas iForks Service Manual

T
ROUBLESHOOTING
Display Messages
2.2

Error Messages

Display
Shows: Meaning:
Err01 Load cell signal is unstable.
Err02 iForks are overloaded.
Err03 Gross weight is negative. This action is not allowed.
Err04 Out of zero range.
Err05 Sampling accuracy too low.
Err06 Input signal too high.
Err08 Calibration out of range (negative).
Err09 Calibration out of range (signal too low).
Calibration count 2nd (3rd) point is lower than count 1st (2nd)
Err10
point.
Err14 Calibration setpoint value 2 < setpoint value 1. This is not allowed. Automatic
Err97 NTEP (OIML) only: Calibration not allowed.
Entered weight used for weight calibration must be higher than
Err98
previous entered weight.
Err99 Button pressed or another action is performed while toggling
between units format (lb or kg).
ErrF1 Problem with iFork 1 (no communication).
ErrF2 Problem with iFork 2 (no communication).
----- Load cell signal negative.
L - _ Forks are out of level (only legal for trade version)
ErrCS Problem with correction sensor
Low Battery Messages
Display
Shows: Meaning:
Battery of display is low
+F1 Fork 1 battery is low
▼
+F2 Fork 2 battery is low
▼
Other Display Messages
Display Shows: Meaning:
BltF1
BltF2
6823346-R3
Successful connection with Fork 1
Successful connection with Fork 2
FK0085.eps
To Exit Error Mode:
Automatic
Automatic after removing weight
Automatic
Press any button
Press any button
Automatic after correcting input
Automatic
Automatic
Automatic
Press "On/Off" button two times. Contact
Cascade Service if calibration is required.
Automatic
Wait for display to return to original unit
format (lb or kg).
Restart display. Restart iForks & display.
Restart display. Restart iForks & display.
Lift up the forks from the ground
Put the forks into horizontal position
Contact the Cascade Service department
FK0086.eps
To Exit Error Mode:
Replace or recharrge the 4 AA batteries
Recharge battery packs or replace the
D cells in both battery packs.
Recharge battery packs or replace the
D cells in both battery packs.
Low Battery
Indicators
5