Maintenance Schedule - Volvo Penta D4 Series Operator's Manual

Maintenance Schedule

Your Volvo Penta engine and its equipment are designed for high reliability and long life. The engines are built to
withstand the marine environment, but also to have the smallest possible environmental impact. If the engine and
transmission are serviced regularly according to the schedule, these qualities will be retained and unnecessary
malfunctions will be avoided.
Warranty inspection
During the initial period of use a special warranty inspection - a First service inspection - must be carried out by
an authorized Volvo Penta workshop. Instructions regarding when this must be done can be found in the Warranty
and service book.
Extended protection for leisure use
Volvo Penta offers extended protection for marine diesel engines, including power trains, applicable only to leisure
boats. For the warranty to be valid, all prescribed services must have been carried out at the owner's expense by
an authorized Volvo Penta dealer or service workshop before the 12 month warranty period has expired. Further
instructions are contained in the Warranty and service book.
C = Clean
R = Replace
A = Adjust
L = Lubricate
I = Inspect (Clean, Adjust, Lubricate or Replace if nec-
essary)
FSI
First Service Inspection, after 50–100 running hours
Coolant level and antifreeze mixture
Fuel pre-filter, draining water / contamination
Drive belt (tension)
Outboard drive, corrosion protection
Outboard drive, oil level in Power Trim
Outboard drive, oil level in Power steering
Start and warm up engine
Engine and transmission, oil / fuel / water leakage (at least 1200 rpm)
Power steering and Power Trim, function and leakage
1) Or within 180 days of the date of delivery, or the end of the first season, whichever comes first.
Every 50-200 Hours / at Least Every 12 Months
Engine Oil and Oil Filters / By-pass filter
1) Oil change intervals vary, depending on engine type, oil grade and sulfur content of the fuel. Se kapitel Oil Grade and Oil
Change Interval.
2) Change the filters during each oil change.
3) The following service point shall be performed after this service point: Engine and transmission, oil / fuel / water leakage (at
least 1200 rpm)
47702599 12-2011
FSI = First Service Inspection
A, B, C, D = Type of service (regular service)
(1)
(1)(2)(3)
I
I
I
I
I
I
I
I
R
67