Volvo Penta D4 Series Operator's Manual page 66

In Case of Emergency
A
2
1
B
P0002515
64
4 Start the engine and let it run at fast idle for approx-
imately 10 minutes to charge the batteries. Make
sure there is no extra equipment connected to the
electrical system.
WARNING!
Working with or going close to a running engine is a
safety risk. Watch out for rotating components and hot
surfaces.
WARNING!
Do not touch the connections during the start attempt:
Risk of arcing.
Do not bend over any of the batteries either.
5 Turn off the engine. Remove the start cables in the
exact opposite order to their connection.
Emergency Shifting
If a fault occurs that prevents engaging gears with the
control lever (shifting), it is possible to engage them
manually.
Reverse gear
This description describes electronically shifted reverse
gear.
Manual shifting of gears
1 Stop the engine and remove the ignition key from
the ignition lock.
2 Unscrew the screw (1) on the side where the cable
harness marked A is connected.
3 Remove the washer (2) and tighten the screw.
4 Disconnect the wiring A and B from the solenoid
valve connections.
The gears are now engaged for forward drive and can-
not be disengaged by the control lever.
47702599 12-2011