Tractor Storage; Daily Storage; Long-Term Storage - Kioti DK4810 Manual

8
 DK4810/5310/5810(Hs)
-

TRAcTOR STORAGE

DAILy STORAGE

1. Keep the tractor clean when it is
stored. make sure to wash it after
work.
2. store it indoors if possible. if it
should be kept outside, cover it.
WARNING
• When operating the tractor in
an enclosed area, ventilate the
area to release exhaust gas to
the outside. The exhaust gas
is colorless and not visible,
but is harmful.
3. r e m o v e t h e b a t t e r y f r o m t h e
tractor in winter and store it in-
doors.
4. add anti-freeze to the tractor in
winter season in order to prevent
the radiator from freezing.
5. remove the ignition key and store
it separately.
TD200-호주향-DK4810,5310,5810(HS)-02 2

LONG-TERm STORAGE

if the tractor will be kept unused for
up to 1 year, follow the following
instructions. this is to operate the
tractor again with minimum prepa-
ration after long-term storage. after
performing the following instructions,
repeat them for the extension period.
ImPORTANT
• If the tractor is not used for
an extended period of time,
follow the instructions below
to prevent corrosion and per-
formance deterioration of the
tractor while it is stored.
1. Check the bolts and nuts for loose-
ness, and tighten if necessary.
2. apply grease to tractor areas whe-
re bare metal will rust also to pivot
areas.
3. Detach the weights from the tractor
body.
4. Inflate the tires to a pressure a lit-
tle higher than usual.
5. Change the engine oil and run
the engine to circulate oil throu-
ghout the engine parts all for
about 5 minutes.
6. Use the clutch locking pin to
keep the clutch disengaged. if
the clutch is left engaged for a
long period of time, the clutch
cover may rust, making clutch
disengagement impossible at the
next operation.
7. With all implements lowered to
the ground, coat any exposed
area such as hydraulic cylinder
piston rods with grease.
8. remove the battery from the
tractor. store the battery following
the battery storage procedures.
(see section "Battery" in Chapter
maintenance.)
9. Keep the tractor in a dry place
where the tractor is sheltered
from rain. Cover the tractor.
2015-02-11 오후 3:02:02