Tractor Storage; Daily Storage; Long-Term Storage - Kioti CK2810 Manual

mX70/mX80/mX90/mX100 mX70/mX80/mX90/mX100
8
5 5
   cK2810 / cK3010H
- - -

TRAcTOR STORAGE

DAILy STORAGE

1. Keep the tractor clean when it is
stored. make sure to wash it after
work.
2. store it indoors if possible. if it
should be kept outside, cover it.
WARNING
•
When operating the tractor in
an enclosed area, ventilate the
area to release exhaust gas to
the outside. The exhaust gas
is colorless and not visible,
but is harmful.
3. remove the battery from the trac-
tor in winter and store it indoors.
4. make sure that anti-freeze(50:50) is
filled enough in radiator in order to
prevent the radiator from freezing.
5. remove the ignition key and store
it separately.
M56(TB110)(CK2810)-호주판-OM-08.ind2 2

LONG-TERM STORAGE

follow the instructions below if the
tractor is not to be used for a long
period of time. this is to operate the
tractor again with minimum prepara-
tion after long-term storage. repeat
this procedure if the tractor hasn't
been used for one year.
IMPORTANT
•
If the tractor is not used for
an extended period of time,
follow the instructions below
to prevent corrosion and per-
formance deterioration of the
tractor while it is stored.
1. check the bolts and nuts for loose-
ness, tighten if necessary.
2. apply grease to tractor areas
where bare metal will rust also to
pivot areas.
3. Detach the weights from the trac-
tor body.
4. inflate the tires to a pressure a
little higher than usual.
5. change the engine oil and run the
engine to circulate oil throughout
the engine parts for about 5 min-
utes.
6. With all implements lowered to the
ground, coat any exposed area
such as hydraulic cylinder piston
rods with grease.
7. remove the battery from the tractor.
store the battery following the bat-
tery storage procedures. (see direc-
tion for storage in every 100hours in
periodic service section)
8. Keep the tractor in a dry place
where the tractor is sheltered from
rain. cover the tractor.
9. store the tractor in a place out of
direct sunlight and heat. if it is un-
avoidable to keep it outside, cover
it with a waterproof cover. lift the
tractor with a jack and place blocks
under its front and rear axles. also,
keep direct sunlight and heat away
from the tires.
2012-10-16 오후 2:58:53