Active Test Menu List - Toyota 8FGU15 Repair Manual

7-110
7.2.3.6 Active Test "ACTIVE TEST"
This function outputs ON/OFF signals to switches in the electrical system and compare controller input sig-
nals with those signals.

Active Test Menu List

Item
SWING SOL*1
STEERING SOL*2
T/C RLY
ASC RLY
LIFT LWR SOL
TILT SOL
TILT BWD SOL
UNLOAD SOL
OPTION RLY
BUZZER*3
SWG TEST
LMP*1
RELEIF SOL
*1: Vehicle with rear stabilizer only
*2: Vehicle with synchronized steering only
*3: Vehicle with OPS buzzer only
*4: T/C interlock specification vehicle only
*5: Depending on the attachment, 3rd to 5th way operation may be possible. Depending on the load, the
forward tilt operation may occur.
*6: It may slowly lower according to load condition, but this is not a fault.
▪ The OFF/ON for each item on the "ACTIVE TEST" screen normally shows the status.
▪ By operating switch (2) or switch (3), the OFF/ON for the selected item will be activated forcibly, and by
operating switch (1) to exchange the item, the forced operation will be released (turn to normal opera-
tion).
▪ A guidance corresponding to switch (2) and switch (3) will show if there is a forced operation. (see table
below)
Description
Swing lock solenoid
forced operation
Steering synchronizer
solenoid forced operation
Forward/reverse travel-
ing interrupt relay forced
operation
Unused
Lift lowering lock solen-
oid forced operation
Tilt solenoid forced oper-
ation
Backward tilt lock solen-
oid forced operation
Unused
T/C interlock relay forced
operation *4
Warning buzzer forced
operation
Swing lock solenoid op-
eration display
Electromagnetic relief
valve forced operation
Selection item
Signal Content of operation
ON Unlock
ON By-pass open
ON Traveling not possible OFF
- -
ON Lowering possible
Forward tilt possible
ON
Backward tilting speed
limited
ON Backward tilt possible OFF
- -
ON Traveling is possible
ON Buzzer ON
ON Indication
Material handling is
ON
possible
7 DISPLAY
Signal Content of operation
OFF Lock
OFF By-pass close
Traveling possible
- -
OFF Lowering not possible
Forward tilt not pos-
sible
OFF
Backward tilt possible
Backward tilt not pos-
sible
- -
Traveling is not pos-
OFF
sible
OFF Buzzer OFF
OFF No indication
Except lowering
OFF
Material handling not
possible *6