Daily Cleaning - Cornelius SPIRE 4.1 Operator's Manual

Spire 4.1 Operator's Manual
M C
ONTHLY
The following cleaning activities are to be performed monthly.
• ) Conduct all daily cleaning activities. See "Daily Cleaning" on page 13.
• ) Flush and sanitize all syrup lines, as well as all of the syrup connectors. See "Sanitizing syrup lines, BIB Systems
(Monthly) - Product Tubing" on page 16.
• ) Remove ice from the hopper. Clean and sanitize the hopper. See "Cleaning and Sanitizing Interior Surfaces
(Monthly)" on page 17.
Sanitizing syrup lines, BIB Systems (Monthly) - Product Tubing
Sanitizing the syrup lines and BIB system should be done monthly.
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit.
All wiring and plumbing must conform to national and local codes. Failure to comply could result in
!
serious injury, death or equipment damage.
WARNING
Perform the following steps to sanitize the syrup lines for BIB systems:
1. Remove all the quick disconnects from all the BIB con-
tainers in the back room.
2. Fill a suitable pail or bucket with warm water and a soap solution.
3. Submerge all the disconnects (gas and liquid) in the soap solution and then clean them using a nylon bristle
brush.
!
Do not use a wire brush.
IMPORTANT
4. Rinse them thoroughly with clean, potable water.
5. Using a large plastic pail, prepare approximately five (5) gallons of sanitizing solution. See "Soap and Sani-
tizing Solutions" on page 13.
6. Soak the BIB disconnects in the sanitizing solution for a minimum of fifteen (15) minutes.
7. Sanitizing fittings must be attached to each BIB discon-
nect. If these fittings are not available, the fittings from
empty BIB bags can be cut from the bags and used.
These fittings open the disconnect so the sanitizing solu-
tion can be drawn through the disconnect
8. Place all the BIB disconnects into the pail of sanitizing solution. Operate all the valves until the sanitizing
solution is flowing from the valve. Allow sanitizer to remain in the lines for fifteen (15) minutes.
Publication Number: 620066826OPR
LEANING
- 16 -
BIB
Container
Quick
Disconnect
Figure 20
Figure 21
© 2017, Cornelius Inc.