Transmission Oil - Malaguti SPIDER MAX GT 500 Service Manual

SPIDER MAX 500 - EURO 3

TRANSMISSION OIL

CHECK LEVEL every 6.000 Km or 12 months
1) Place the vehicle on a level surface, on the central stand.
2) Release the dipstick (A), clean it, then fit it back tightening it completely.
3) Extract it again and check that the oil level is between the MAX and MIN marks.
4) If the oil level is low, top it up to the MAX mark.
5) Refill the case with oil: Q8 ZC 90
Case capacity: around 250 cc.
REPLACE first time after 1.000 Km and then every 24.000 Km
Perform the operations described at points: 1 - 2 without refitting the graduated dipstick, then place a container
beneath the engine crankcase and release the drain screw (B), taking care not to damage the gasket
Let the oil drain into the container for a few minutes (taking care to avoid burns).
Refit the drain plug and the gasket and top up with around 250 cc of new oil (Q8 ZC 90) then fit the oil plug with the
dipstick (A).
At this point, repeat the check operations indicated at point 3-4-5. Replace the drain screw gasket if necessary.
Check for oil leaks in the areas near the drain plug, rear wheel.
A
F. 5
Max
Min
F. 6
19 07/06
B
B