Catalytic Liners - Parmco PPOV-9S-48 Installation And Operating Instructions Manual

Catalytic Liners

The removable catalytic liners are coated with a dark gray catalytic coating that can become marked with
oil and fat during cooking. These deposits will burn off at oven temperatures of 200 °C and higher.

Higher temperatures will result in faster burning. The oven and accessories should be cleaned
after each use. Otherwise further baking and roasting will cause the deposits to bake on even
harder and cleaning may become difficult and in extreme cases impossible.
Make sure the oven is cool before cleaning by hand.

The catalytic liners should be cleaned using a solution of hot water and dish washing liquid
applied with a soft nylon brush

Do not wash in the dishwasher

Do not use abrasive cleaning agents, hard brushes, scouring pads or cloths, steel wool, knives or
other abrasive materials

Do not use oven spray on catalytic panels as the chemicals used in oven sprays will damage
catalytic liners and render them

If using oven sprays on the interior oven surfaces, the catalytic liners must first be removed from
the oven
Before cleaning the catalytic liners using high oven temperatures make sure that all interior oven surfaces
have been cleaned as described above. Otherwise, the high temperatures can bake deposits onto the
interior oven surfaces and make them impossible to remove.

Remove all accessories from the oven.

Set the oven to conventional bake function.

Set the heat to 250 °C.

Run the oven for approximately 1 hour. The length of time will depend on the degree of soiling.

It is a good idea to set the finish time for the process using the end time setting, in case you
forget to switch the oven off.

Any remaining soil will gradually disappear with each subsequent use of the oven at high
temperatures. The stains on the catalytic liners caused by grease, fats and oils from cooking are
completely normal and will not be able to be completely removed.

Catalytic liners are a consumable item and can be replaced with new catalytic liners.
17