Easy Checker(Tm) - Kubota M5N-091 Operator's Manual

BEasy Checker(TM)
If the warning indicators in the Easy Checker(TM) come
on during operation, immediately stop the engine, and find
the cause as shown below.
Never operate the tractor while Easy Checker(TM)
indicator is on.

(1) Easy Checker(TM)

Engine warning
This indicator serves the following two functions. If the
warning indicator lights up, pinpoint the cause and
take a proper measure.
1. Error with the engine control system
If during operation the water temperature gauge reads
an acceptable level but the warning indicator in the
Easy Checker(TM) comes on, stop the engine and get
it restarted. If the error happens again, consult your
local KUBOTA Dealer.
A If the warning indicator lights up, the following
phenomena may appear depending on the engine's
trouble spot.
A The engine stops unexpectedly.
A The engine fails to start or gets interrupted just
after start.
A The engine output is not enough.
A The engine output is enough, but the warning
indicator stays on.
If the engine output is not enough, immediately
interrupt the operation and move the tractor to a safe
place and stop the engine.
2. Engine overheat
If the water temperature gauge reads an unusual level
and the warning indicator in the Easy Checker(TM)
comes on, the engine may have got overheated.
Check the tractor
"TROUBLESHOOTING" section.
by referring to
OPERATING THE TRACTOR
Engine oil pressure
If the oil pressure in the engine goes below the
prescribed level, the warning indicator in the Easy
Checker(TM) will light up.
If this should happen during operation, and it does not
go off when the engine is accelerated to more than
1000 rpm, check level of engine oil.
(See "Checking Engine Oil Level" in "DAILY CHECK"
in "PERIODIC SERVICE" section.)
DEF/AdBlue® system warning
If trouble should occur at the DEF/AdBlue® system,
the warning indicator in the Easy Checker(TM) will
light up.
If this should happen during operation, check the DEF/
AdBlue® system or consult your local KUBOTA
Dealer.
Fuel level
If the fuel in the tank goes below the prescribed level,
the indicator in the Easy Checker(TM) will come on.
(less than 17 L (4.9 gals.))
If this should happen during operation, refuel as soon
as possible.
(See "Checking and Refueling" in "DAILY CHECK" in
"PERIODIC SERVICE" section.)
A When the fuel indicator lights up, refuel the tank as
soon as possible. If the tractor runs out of fuel and
stalls, the engine and its components may be
damaged.
Water separator
If water or impurities collect in the water separator, the
indicator in the Easy Checker(TM) will light up.
If this should happen during operation, drain the water
from the water separator as soon as possible.
(See "Checking Water Separator" in "DAILY CHECK"
in "PERIODIC SERVICE" section.)
DEF/AdBlue® level
If the DEF/AdBlue® in the tank goes below the
prescribed level, or if a poor-quality product is added,
the indicator in the Easy Checker(TM) will right up.
If this should happen during operation, refill or replace
with DEF/AdBlue® as soon as possible.
(See "Selective Catalytic
MUFFLER" in "OPERATING THE ENGINE" section.)
Emission indicator
If this indicator lights up, take the steps to lower the
water temperature. This helps keep the emission
clean.
45
Reduction (SCR)