Glass - GMC 1976 ZEO 6083 Maintenance Manual

MOTORHOME AND TRANSMODE PAINT CODES
MOTOR HOME and TRANSMODE PAINT CODES
INSTRUMENT PANEL PAINT CODES
Pontiac
nt Code Coatings Refinish
No . Code No . No .
864-AF738 9994LH
864-AF941 42911LH
864-AF038
GMT 544
GMT 551
R PAINT CODES
*Effective with vehicle serial number TZE165V100089, vehicles are being painted with DuPont urethane paint
trademarked IMRON. Paint repairs should be made with IMRON (DuPont refinish No . ends in U) or equivalent or a
high grade enamel (DuPont acrylic enamel refinish No . ends with A) automotive paint.
NOTE : Lacquer should not be used to repair body finish on these vehicles .
WINDSHIELD REPLACEMENT
Windshield glass is retained in the opening by a
molded rubber weatherstrip with an insert-type rub-
ber seal as shown in Figure 1 . Two glass sections are
used in this vehicle .
When replacing a cracked windshield glass, it is
very important that the cause of the glass breakage
be determined and the condition corrected before a
new glass is installed. Otherwise, it is highly possible
that a small obstruction or high spot somewhere
Figure 1-Windshield Weatherstrip
A-1955
GLASS
BODY 1- 5
around the windshield opening will continue to crack
or break the newly installed windshield ; especially
when the strain on the glass caused by the obstruc-
tion is increased by such conditions as wind pres-
sures, extremes of temperature, motion of the
vehicle, etc.
REMOVAL
If cracks in glass extend to outer edge of glass,
mark body with chalk at these points so that wea-
therstrip flange opening can be examined later for
possible distortion .
Protect the interior finish by placing a protective
covering over steering wheel and dash panel . Mask
around the windshield opening and lay a suitable
cover to protect body .
WARNING: ALWAYS WEAR HEAVY GLOVES
TO PREVENT POSSIBLE INJURY WHEN HAN-
DLING GLASS.
1 . Pry end of insert out of rubber seal with a
pointed tool ; pull insert completely out of seal .
RPO
690, 692
693, 695
696
697
697
698
D u P o C o l o r Fisher No .
Midnight Neutral W25A-4300
Dark Amber W25A-4530
Dark Saddle W25A-4098
Dark Saddle GMT-544
Dark Lime GMT-551
EXTERIO
Chamois WEA-4326
Beige* WUEK-4527
White* WUEK-5111
Buttercup Yellow* WUEK-5241
Frosted Mint* WUEK-5254
Aspen Gold* WUEK-5267
Cameo White* WUEK-3967
Yellow* WUEK-5269
Cream White* WUEK-5222
525
534
521
531
553
557
558
580
585
5481 5481A
826-Y-AF926 42807U
826-Y-21667 817U
826-Y-AH434 43916U
826-Y-AH541 44017U
826-Y-AH580 44313U
826-Y-99642 5338U
826-Y-AH640 44365U
826-Y-AH718
44570U