Cadillac 60 Series 1963 Shop Manual page 557

16-88
BODY
Notch In Vinyl
At Centerline
Water Barrier L Trim Webbing
Vi" Above Curtain
Zipper Tape
Nylon non-Staining
Type Webbing
Forward End Of
L
Rear Quarter
Trimstick
Tacks
View In Direction Of Arrow "A'
Fig. 16-103 Back Curtain Installation
should not be pulled taut after back curtain has
been installed to rear roof bow as zipper
assembly may show through top material after
top has been properly installed.
10. Tack remainder of back curtain material to
rear quarter trim stick, turning forward edge of
material rearward to form a water barrier, Fig.
16-103.
11. Tacks securing back curtain assembly to
trim sticks should be placed close to each side
of every bolt hole in trim sticks; then pierce or
punch back curtain assembly for each trim stick
bolt.
12. Tack nylon webbing to rear trim stick.
Forward edge of webbing should be even with
Fillers
Right Wheelhouse Drain Gutter
Inner Panel
Stay Tack Curtain
To Rear Bow
Back Curtain Assembly
Fig. 16-105 Tacking Back Curtain at Rear Bow
edge of rear trim stick. New webbing may be
cut from a piece of non-staining type webbing
2 inches x 19 inches. Excess webbing should be
trimmed off at rear trim stick, 1/2 inch above
back curtain lower edge, Fig. 16-103.
NOTE: Webbing used in build-up of side roof
rail stay pads is recommended for the above
operation.
13. Inspect rubber trim stick fillers cemented
to body below pinchweld. Re-cement, if necessary,
Fig. 16-104.
14. Install rear trim stick with attached back
curtain assembly into body.
NOTE: Make sure that all trim stick bolts
are driven completely in to represent finished
condition.
1.5. Secure back curtain assembly with one tack
to rear bow to prevent damage to plastic sheet,
Fig. 16-105.
16. Working from body center progressively
outboard to right: and left sides, tack back curtain
upper valance to rear body. Make sure all full-
ness has been drawn from curtain assembly. Fold
excess back curtain upper valance material rear-
ward and tack to rear bow, Fig. 16-106.
Rear Roof Bow
Fold Excess Material Rearward
Fig. 16-104 Checking Trim Stick Fillers
Fig. 16-106 Back Curtain Installation at Rear Bow